Yanmar SA Series - TROUBLESHOOTING; Using the Troubleshooting Guide; Engine Problems

17. TROUBLESHOOTING
17-1
SA221/324/424 Operation Manual
17. TROUBLESHOOTING
The troubleshooting table given below is quick reference for solving common problems.
If any fault, failure or a problem requiring repair work is found, contact YOUR LOCAL YANMAR
TRACTOR DEALER for technical assistance.
1. Engine
1. How to Use the Troubleshooting Table
The problem is: The possible cause(s) are: Remedy:
The engine is hard to
start or does not start
at all
1. A problem in the electrical 1. Electrical system
• Check whether the battery is fully
charged.
• charge the battery
• Check whether the fuse/s is/are
blown.
• make sure the electric harnesses
are not faulty and replace the blown
fuse/s
• Check for loose or corroded the
battery terminals and battery cables.
• tighten the loose battery terminals
• clean the corroded battery
terminals and battery cables
• Check whether the start relay is
faulty.
• replace start relay
• Check whether the starter key switch
is faulty.
• contact YOUR LOCAL YANMAR
TRACTOR DEALER
• Check whether the starter is faulty.
• contact YOUR LOCAL YANMAR
TRACTOR DEALER
• Check whether the glow plug is faulty.
• contact YOUR LOCAL YANMAR
TRACTOR DEALER
• Check whether the interface
combination functions correctly.
• contact YOUR LOCAL YANMAR
TRACTOR DEALER
START
PARKING FORWARD/REVERSE PEDAL-N PTO (N)
SA221_324_424_OperatorsManual.book 1 ページ ２０１８年６月４日 月曜日 午後５時１９分