York DM SERIES - Page 2

5011492-XIM-B-0815
2 Johnson Controls Unitary Products
LIST OF TABLES
1 Unit Application Data (DM) . . . . . . . . . . . . . . . . . . . . . . . . 8
2 Control Wire Sizes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
3 Electric Heater Supply Air Limitations . . . . . . . . . . . . . . . 14
4 Gas Heat Application Data . . . . . . . . . . . . . . . . . . . . . . . 14
5 Gas Pipe Sizing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
6 Single Enthalpy and Dual Enthalpy High Limit Curves. . 18
7 Simplicity SE Economizer Board Details . . . . . . . . . . . . 21
8 DM 4 Point Loads Weight Distribution (kg / lbs) . . . . . . . 25
9 DM 6 Point Loads Weight Distribution (kg / lbs) . . . . . . . 25
10 Center Of Gravity (All Models) . . . . . . . . . . . . . . . . . . . . 25
11 DM036-076 Physical Data . . . . . . . . . . . . . . . . . . . . . . . 26
12 Operating Weights (kg / lbs.) . . . . . . . . . . . . . . . . . . . . . . 26
13 Electrical Data DM 036-076 . . . . . . . . . . . . . . . . . . . . . . 27
14 Electric Heat Correction Factors . . . . . . . . . . . . . . . . . . . 27
15 Voltage Limitations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
16 Utilities Entry . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
17 Minimum Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
18 Supply Air Blower Performance (3 & 4 Ton Direct Drive) -
Side Duct Application . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
19 Supply Air Blower Performance (5 Ton Belt Drive) - Side
Duct Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32
20 Supply Air Blower Performance (6.3 Ton Belt Drive) - Side
Duct Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33
21 Belt Drive Motor And Drive Data . . . . . . . . . . . . . . . . . . . 34
22 Static Resistances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
23 Limit Control Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
24 Electric Heat Anticipator Setpoints . . . . . . . . . . . . . . . . . 39
25 Limit Control Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
26 Gas Heat Anticipator Setpoints . . . . . . . . . . . . . . . . . . . . 40
27 Gas Rate - Cubic Feet Per Hour . . . . . . . . . . . . . . . . . . . 43
28 Unit Control Board Flash Codes . . . . . . . . . . . . . . . . . . . 50
29 Ignition Control Board Flash Codes . . . . . . . . . . . . . . . . 50
30 Simplicity SE UCB Details . . . . . . . . . . . . . . . . . . . . . . . 53
LIST OF FIGURES
1 Recommended Drain Piping . . . . . . . . . . . . . . . . . . . . . . 9
2 Compressor Restraining Bracket . . . . . . . . . . . . . . . . . . . 9
3 Typical Field Power & Simplicity Lite Dm036-076 Control
Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
4 Typical Simplicity SE Control Wiring . . . . . . . . . . . . . . . 12
5 External Supply Connection External Shut-off . . . . . . . . 15
6 Bottom Supply Connection External Shut-off . . . . . . . . . 16
7 Vent And Combustion Air Hood . . . . . . . . . . . . . . . . . . . 16
8 Economizer LCD and Keypad Layout. . . . . . . . . . . . . . . 17
9 Single Enthalpy Curve And Boundaries . . . . . . . . . . . . . 18
10 SE-ECO1001-0 Economizer Controller . . . . . . . . . . . . . 21
11 Four And Six Point Loading . . . . . . . . . . . . . . . . . . . . . . 25
12 Unit Dimensions (3 - 6.3 Ton Cooling Only/electric Heat)
Front View . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
13 Unit Dimensions (3 - 6.3 Ton Cooling/gas Heat) Front
View . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
14 Unit With Economizer Rainhood . . . . . . . . . . . . . . . . . . 29
15 Unit With Fixed Outdoor Air/motorized Damper
Rainhood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
16 Unit Dimensions (Rear View) . . . . . . . . . . . . . . . . . . . . . 30
17 Disconnect/blower Access Location . . . . . . . . . . . . . . . 30
18 Belt Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
19 Pressure Drop Across Coil . . . . . . . . . . . . . . . . . . . . . . . 36
20 Gas Valve Piping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
21 Proper Flame Adjustment . . . . . . . . . . . . . . . . . . . . . . . 42
22 Typical Gas Valves . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
23 Typical Flame Appearance . . . . . . . . . . . . . . . . . . . . . . 42
24 Unit Control Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
25 Unit Control Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
26 Typical DM036, 048 With Simplicity Lite Control, With/
without Electric Heat Wiring Diagram . . . . . . . . . . . . . . 59
27 Typical DM036, 048 With Simplicity Lite Control, With Gas
Heat Wiring Digram . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
28 Typical DM060, 076 with Simplicity Lite Control, With/
Without Electric Heat Wiring Digram . . . . . . . . . . . . . . . 61
29 Typical DM060, 076 With Simplicity Lite Control, With Gas
Heat Wiring Digram . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
30 Typical DM036, 048 With Simplicity SE Control, With/
without Electric Heat Wiring Diagram . . . . . . . . . . . . . . 63
31 Typical DM036, 048 With Simplicity SE Control, With Gas
Heat Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
32 Typical DM060, 076 With Simplicity SE Control, With/
without Electric Heat Wiring Diagram . . . . . . . . . . . . . . 65
33 Typical DM060, 076 With Simplicity SE Control, With Gas
Heat Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . 66