York ZE036 - ZE036-060 Cooling Only;Electric Heat Front View Physical; Dimensions; ZE036-060 Cooling Only;Gas Heat Front View Physical

81 pages

To Next Page

To Previous Page

5188235-YIM-B-1016

Johnson Controls Unitary Products 9

Figure 5: ZE036-060 Cooling Only/Electric Heat Front View Physical Dimensions

Figure 6: ZE036-060 Cooling Only/Gas Heat Front View Physical Dimensions

Main Page

Table of Contents1
General2
Installation5
- Installation Safety Information5
- Limitations5
- ZE036-060 Unit Limitations6
- ZE036-060 Component Location6
  - Location7
  - Rigging and Handling7
- Ze036-0608
- ZE036-060 Unit Accessory Weights8
- Unit 4 Point Load Weight8
- Unit 6 Point Load Weight8
- Center of Gravity8
- ZE036-060 Cooling Only/Electric Heat Front View Physical9
  - Dimensions9
- ZE036-060 Cooling Only/Gas Heat Front View Physical9
- ZE036-060 Unit Clearances10
- ZE036-060 Fixed Outdoor Air Motorized Damper Rain Hood Physical Dimensions10
- ZE036-060 Disconnect Location10
- ZE036-060 Utilities Entry11
- ZE036-060 Unit Side Duct Openings11
ZE036-060 Roof Curb11
- Ductwork12
- Condensate Drain12
- Compressors12
- Filters13
- Power and Control Wiring13
Compressor Restraining Bracket13
- Control Wire Sizes14
Typical Field Power and Control Wiring15
- Typical Power Wiring15
- Typical Cool/Heat Control Wiring (Simplicity Lite ZE036-060)15
Typical Field Power and Simplicity Lite Control Wiring15
- Typical Cool/Heat Control Wiring16
Typical Smart Equipment™ Control Wiring16
- Electrical Data17
- ZE036-060 Physical Data29
  - Optional Electric Heat31
- Electric Heat Minimum Supply Air31
Gas Heat Application Data31
Gas Pipe Sizing - Capacity of Pipe32
Side Entry Gas Piping32
- Bottom Entry Gas Piping32
- Options/Accessories34
- RRS Economizer Interface Overview34
- Vent and Combustion Air Hood34
- RRS Economizer LCD and Keypad Layout34
- Smart Equipment™ Economizer Sequences35
- Dry Bulb Changeover35
- Single Enthalpy Changeover35
- Dual Enthalpy Changeover35
- Auto35
- Free Cooling Operation35
- Power Exhaust36
- Operation36
Smart Equipment™ Economizer Board Details37
SE-ECO1001-0 Economizer Controller37
- Jade Economizer Interface Overview40
  - Jade Economizer LCD and Keypad Layout40
  - Single Enthalpy Curve and Boundaries41
Single Enthalpy and Dual Enthalpy High Limit Curves42
Altitude/Temperature Correction Factors43
- Belt Adjustment43
Altitude/Temperature Correction Factors44
ZE Blower Performance Side Duct46
ZE Blower Performance Bottom Duct48
Belt Drive RPM Selection49
Indoor Blower Specifications (Belt Drive)49
Power Exhaust Specifications49
- Checking Supply Air CFM50
Additional Static Resistance50
Pressure Drop Across Coil50
Operation51
- Cooling Sequence of Operation51
  - No Outdoor Air Options51
  - Cooling Operation Errors51
- Electric Heating Sequence of Operations53
  - Electric Heat Operation Errors53
Electric Heat Limit Setting53
- Gas Heating Sequence of Operations54
- Gas Heat Operation Errors54
Electric Heat Anticipator Setpoints54
- Gas Valve Piping54
Single Stage Gas Heat Limit Control Setting55
24 2 Stage Gas Heat Limit Control Setting55
- Flash Codes or Error Messages56
- Resets56
  - Heat Anticipator Setpoints56
Start-Up (Cooling)56
Start-Up (Gas Heat)56
Gas Heat Anticipator Setpoints56
Typical Single Stage Gas Valves57
Typical 2 Stage Gas Valves57
- Proper Flame Adjustment57
Checking Gas Input58
Troubleshooting58
Gas Rate-Cubit Feet Per Hour58
Typical Flame Appearance58
ZE036 (3.0 Ton) Operating Pressures61
ZE048 (4.0 Ton) Operating Pressures61
ZE060 (5.0 Ton) Operating Pressures62
Simplicity Lite Unit Control Board Flash Codes66
Ignition Control Board Flash Codes66
Simplicity Lite Control Board66
Smart Equipment™ Control Board Navigation Components67
- Smart Equipment™ Firmware Version 3.1 Basic Unit Control Board Navigation Examples68
Smart Equipment™ UCB Details70
Smart Equipment™ Unit Control Board70
Cable for FC Buses and SA Buses in Order of Preference75
- Start-Up Sheet76

York ZE036 - ZE036-060 Cooling Only;Electric Heat Front View Physical; Dimensions; ZE036-060 Cooling Only;Gas Heat Front View Physical

Table of Contents

Other manuals for York ZE036

Related product manuals