Amana AFD2535DES - User Manual

Service Specifications Bottom Mount RefrigeratorTechnical Information
AFD2535DEB AFD2535DEB0, AFD2535DEQ AFD2535DEQ0,
AFD2535DES AFD2535DES0, AFD2535DEW AFD2535DEW0,
MFD2560HEB MFD2560HEB0, MFD2560HEQ MFD2560HEQ0,
MFD2560HES MFD2560HES0, MFD2560HEW MFD2560HEW0
!
WARNING
To avoid risk of electrical shock that can cause death or severe personal injury, disconnect unit from power before
servicing unless tests require power. Discharge capacitors through a 10,000-ohm resistor before handling. Wires
removed during disassembly must be replaced on correct terminals to ensure proper grounding and polarization.
Due to a possibility of personal injury or property damage, always contact an authorized technician for
service or repair of this refrigerator.
3. Release the refrigerator door light switch.
4. The control will display Fd to confirm entry into the Forced Defrost Mode.
Freeze
r
Refri
g
CAUTION
!
F
erator
All safety information must be followed as provided in Service Manual 16022769.
5. Entry is confirmed by pressing the Refrigerator Down
key once more. The unit is off and in the Defrost Mode.
Note: All control functions will be turned off (Compressor, Defrost, Evaporator Fan, the damper will
remain in its current position).
!
WARNING
6. The control will default to the short run period test as shown here:
Freeze
r
Re fri
g
erato
r
S
To avoid risk of electrical shock that can cause death or severe personal injury, disconnect unit from power before
servicing unless testing is required. Discharge capacitors through a 10,000 ohm resistor before handling. Wires
removed during disassembly must be replaced on correct terminals to ensure proper grounding and polarization.
Note: You can toggle between the (S)hort and (L)ong test mode by pressing the Refrigerator UP
Key.
Long Test mode is used for factory test and should not be used in the field.
Freezer Refri
g
erat
No-Load Performance, Controls in Normal Position
Kw/24 hr ±0.4
Percent Run Time
±10%
Cycles/24 hr
±25%
Refrigerator Center
Compartment
Average Food
Temperature ±3°F
Freezer Compartment
Average Food
Temperature ±3°F
Ambient °F 70° 90° 110° 70° 90° 110° 70° 90° 110° 70° 90° 110° 70° 90° 110°
25 cu ft 1.0 1.60 2.3 28 48 65 35 39 25 38 36 35 0 0 0
or
L
7. Once the desired mode is displayed, confirm the forced defrost by pressing the Refrigerator
down Key once.
The defrost will begin immediately and the display will return to a normal operating display with set point values.
Freeze
r
Refri
g
erator
4
4
Temperature Relationship Test Chart
Evaporator
Outlet
±3°F
Evaporator
Inlet
±3°F
Suction Line
±7°F
Average Total
Wattage ±10%
Suction
Pressure
±2 PSIG
Head Pressure
± 5 PSIG
Ambient °F 70° 90° 70° 90° 70° 90° 70° 90° 70° 90° 70° 90°
25 cu ft -20 -17 -20 -17 85 105 135 140 6"(Vac.) 0 87 137
8. Close the Refrigerator door(s). You are in the defrost mode
Note: Forced Defrost mode can be exited at any time prior to step 7 by closing the Refrigerator Door(s).
Service Test Mode:
The service test functions are performed using the refrigerator display and keypad. Enter the Service Test Mode
by performing the following sequence of events:
1. Hold the refrigerator door light switch closed.
Schematic
2. Press the Refrigerator Temperature Up
keypad 3 times consecutively.
Note: The 3 Keystrokes must be done consecutively and within 10 seconds.
3. Release the refrigerator door light switch.
4. The control will display SE to confirm entry into the service mode.
Freeze
r
Re
S
fri
g
erator
E
5. Entry to the Service Menu is confirmed by pressing the Refrigerator Up key once more.
6. The control will display its software version for 3 seconds.
Freez
2
er Refri
g
erato
r
5
7. Following the software revision display the freezer display will read the first test number in the
diagnostic tree. The refrigerator display will be blank.
Freeze
r
1
Refri
g
erator
Note: All control functions will be turned off (Compressor, Defrost, Evaporator Fan, the damper will
remain in its current position).
8. You are now in the SERVICES TEST operational mode and may use the diagnostic tests.
The Service Test Mode can be exited at any time by closing the Refrigerator Door(s).
April 2004 4 16023133 April 2004 1 16023133
© 2004 Maytag Services © 2004 Maytag Services

Summary

Service Specifications Overview

Forced Defrost Mode Procedure

Steps to enter and confirm the Forced Defrost Mode using the refrigerator keypad.

Service Test Mode Entry

Procedure to enter the Service Test Mode via refrigerator display and keypad.

Technical Data and Performance

No-Load Performance Data

Table detailing performance metrics at various ambient temperatures under no-load conditions.

Temperature Relationship Test Chart

Chart illustrating temperature correlations across different ambient conditions.

Electrical Schematic Diagram

Wiring diagram showing electrical components and their connections for the unit.

Component and System Specifications

Component Specifications Table

Detailed specifications for various refrigerator components like compressor, motors, and heaters.

Programming Mode Entry

Steps to enter the Programming Mode using the fresh food door light switch and keypad.

Defrost Operation Details

Explanation of defrost cycle adaptation, timing, and termination criteria.

Service Testing Procedures

Wiring Diagram Explanation

Notes on wiring, including alternate wiring for the fresh food mullion heater.

Service Test 1: Defrost Thermostat & Circuit

Test to check defrost thermostat state and observe defrost heater operation.

Service Test 2: Compressor;Condenser Fan

Test to evaluate proper operation of the compressor and condenser fan.

Service Test 3: Evaporator;Freezer Fan

Test to check the function and operation of the freezer fan.

Diagnostic Tests and Adjustments

Service Test 4: Fresh Food Thermistor Test

Tests the Fresh Food Thermistor circuit for Pass, Open, or Short results.

Service Test 5: Freezer Thermistor Test

Tests the Freezer Thermistor circuit for Pass, Open, or Short results.

Service Test 6: Open Damper Test

Tests the refrigerator damper position (Open/Closed) and function.

Service Test 7: FF Performance Adjustment

Allows adjustment of the refrigerator's performance points.

Service Test 8: FZ Performance Adjustment

Allows adjustment of the freezer's performance points.

Amana AFD2535DES Specifications

General

Type	French Door
Configuration	Top Freezer
Ice Maker	Yes
Water Dispenser	Yes
Color	Stainless Steel
Width	35.75 inches
Depth	33 inches
Height	69.875 inches
Energy Star	Yes
Defrost Type	Frost-Free
Energy Star Certified	Yes
Total Capacity	25.0 cu. ft.