Apollo Hydroheat A650YRRTL5 User Manual

ALL TECHNICAL AND WARRANTY QUESTIONS: SHOULD BE DIRECTED TO THE LOCAL DEALER FROM
WHOM THE WATER HEATER WAS PURCHASED. IF YOU ARE UNSUCCESSFUL, PLEASE WRITE TO THE
COMPANY LISTED ON THE RATING PLATE ON THE WATER HEATER.
GAMA certification applies to all
residential gas water heaters with
capacities of 20 to 100 gallons
with input rating of 75,000
BTU/Hr. or less.
–Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
–WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not
use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone. Follow the gas suppli-
er’s instructions.
• If you cannot reach your gas supplier, call
the fire department.
–Installation and service must be performed
by a qualified installer, service agency or
the gas supplier.
WARNING: If the information in these
instructions are not followed exactly, a fire
or explosion may result, causing property
damage, personal injury or death.
Improper installation, adjustment, alteration,
service or maintenance can cause DEATH,
SERIOUS BODILY INJURY, OR PROPERTY
DAMAGE. Refer to this manual for assistance
or consult the local gas utility for further
information.
WARNING
Flammable vapors may be drawn by air cur-
rents from other areas of the structure to this
appliance.
WARNING
READ THE GENERAL SAFETY SECTION
BEGINNING ON INSIDE COVER AND THEN
THIS ENTIRE MANUAL BEFORE INSTALLING
OR OPERATING THIS WATER HEATER.
WARNING
Save this Manual for Future Reference.
For Your Safety
AN ODORANT IS ADDED TO THE GAS
USED BY THIS WATER HEATER
Instruction Manual for
Residential
Gas Water Heaters
NOT FOR USE IN MANUFACTURED (MOBILE) HOMES
184115-000
03-03

Apollo Hydroheat A650YRRTL5 Specifications

General

Brand	Apollo
Model	Hydroheat A650YRRTL5
Category	Water Heater
Language	English

Summary

General Safety

Vent Dampers

Guidance on vent damper installation and removal for proper operation.

Water Leakage Prevention

Measures to prevent property damage from potential water leaks.

Introduction

Manual Abbreviations

List of abbreviations used throughout the instruction manual.

Preparing for Installation

Typical Installation

Locating the Water Heater

Location Considerations

Key factors for selecting a safe and efficient water heater location.

Combustion Air and Ventilation

Requirements for adequate air supply for the water heater's operation.

Installing the Water Heater

Water Piping

Instructions for connecting water supply and return lines.

Temperature-Pressure Relief Valve

Installation and operation of the safety relief valve.

Filling the Water Heater

Procedure for filling the tank before initial operation.

Venting Installation

Guidelines for proper vent pipe connection and slope.

Gas Piping

Connecting the gas supply line safely and correctly.

Installation Checklist

Pre-lighting checks for a safe and correct installation.

Lighting the Water Heater

Gas Leak Safety Procedures

Critical steps to take if a gas leak is detected.

Pilot Lighting Instructions

Step-by-step guide to safely light the pilot flame.

Turning Off Gas

Procedure to shut off the gas supply to the appliance.

Temperature Regulation

Adjusting Water Temperature

How to set and adjust the water temperature for safety and comfort.

For Your Information

Start Up and Operational Conditions

Information on initial operation, condensation, and smelly water.

Hot Water Supply Issues

Troubleshooting insufficient or excessively hot water supply.

Periodic Maintenance

Venting System Inspection

Annual checks for venting system integrity and obstructions.

Burner Maintenance

Inspection and cleaning procedures for the burner assembly.

Anode Rod and Relief Valve Maintenance

Checking the anode rod and testing the relief valve.

Draining and Drain Valve Service

Procedures for draining the tank and servicing the drain valve.

Leakage Checkpoints

Repair Parts

Ordering Repair Parts

Information and requirements for ordering replacement parts.

Notes