Aquatech Pressmain MG-L - General Safety Information; Warnings

TankmaticSmartRelay

Aquatech‐PressmainInstructionmanual\TankmaticsmartrelayMG‐LT  3 

 0.GENERALSAFETYINFORMATION 

 Theseinstructionsareintendedfortheinstaller/operator/user/maintenanceofthisequipment
andmustbekeptwiththeequipment,forthelifeoftheequipmentandmadeavailabletoall
persons.PleasereadGENERALSAFETYINFORMATION0.0,WARNINGS0.1andCAUTIONS0.2,0.3&
0.4beforedoinganythingelse,andthenfollowthemcarefully.
 Theunitmustonlybeinstalled/operated/used/maintainedbyacompetentperson;Acompetent
personissomeonewhoistechnicallycompetentandfamiliarwithsafetypracticesandthehazards
involved.
 HydraulicAccumulators/ExpansionVesselsinstalledaspartof/inconjunctionwiththisequipment,
withPressurexVolumeabove250Bar‐litres,requireregularformalinspectionbyacompetent
person.ThisisaLegalRequirementunderthe“PressureSystemsSafetyRegulations”(PSSR)and
theOwner/Usershouldbemadeawareoftheirresponsibilityforthis.(seesection3.Servicing).
 Failuretoinstall/operate/use/maintaintheequipmentasrecommendedbelowcouldcause
damagetotheequipmentanyanythingsubsequentlyconnectedtoit,andinvalidatethewarranty
providedbyAquaTech‐Pressmaintothebuyer.
 Anydamagecausedtotheequipmentbymisapplication,mishandlingormisusecouldleadtorisk
ofElectrocution,Burns,Fire,Floodingorinjurytopeopleorpropertydependentuponthe
circumstancesinvolved.
 ThisequipmentMAYcontainmoving/rotatingpartsthatmustremainguarded.Removalofor
missingguardscouldleadtoseriouspersonalinjury.
 Thisequipmentautomaticallyrestartsafterapowerinterruption.
 Weacceptnoresponsibilityorliabilityforanyconsequencesordamage/lossesdueto
misapplication,mishandlingormisuseoftheequipment.
 Itshouldbenotedthattheassemblyofpressureequipmentonsiteundertheresponsibilityofthe
user(orhisrepresentative)isnotsubjecttothePressureEquipmentDirective97/23/EC.(National
legislationcoveringassemblyonsitewillapply)
 Thelatestversionofthisinstructionmanualwithuptodatesafetyinformationcanbedownloaded
fromourwebsiteatwww.aquatechpressmain.co.uk

0.1 WARNINGS
0.1.1 Donottouchanylivepartsforatleast5minutesafterswitchingofftheelectricitysupply.Failureto
observethiswillconstituteasevereElectricshockand/orBurnshazardandmaybelethal.
0.1.2 Theequipmentisonlysuitableforearthreferencedsuppliesandmustbepermanentlyearthedto
avoidElectricshockhazard.
0.1.3 WithequipmentisolatorOFF,mainsvoltagemaystillbepresentfromBMSsystem.Thisconstitutes
anElectricshockhazard.
0.1.4 Emergencystopbuttondoesnotremovedangerousvoltagesfromcontrolpanel/pumpmotor
assemblies.ThisconstitutesanElectricshockhazard.
0.1.5 Metalparts(e.g.heatsinks)mayreachtemperaturesof90degreescentigradeandwillconstitutea
Burnshazard.
0.1.6 Someequipmentisdesignedtooperatewithliquidtemperaturesupto150degreescentigradeand
willconstituteaBurns/scaldinghazard.