Argo V896-65 User Manual

Argo Service Manual Electrical System
Ontario Drive & Gear Limited www.odg.com
PH.(519)- 662-2840 FAX (519)- 662-2421
ES-1
Table of Contents
SECTION ES
Electrical System
General Instructions............................................................................. ES-5
Battery.................................................................................................... ES-6
Checking Battery Fluid Level.............................................................. ES-6
Charging the Battery.............................................................................ES-6
Cleaning the Battery Terminals & Cable Connections......................ES-6
Cleaning the Battery..............................................................................ES-7
Battery Removal....................................................................................ES-7
Battery Inspection................................................................................. ES-7
Battery Installation............................................................................... ES-8
Changing a Headlamp Bulb (Earlier Conquest Models)...................ES-8
Installing the Headlamp Bulb (Earlier Conquest Models)................ES-9
Removing a Headlamp Bulb................................................................ES-9
Installing a Headlamp Bulb..................................................................ES-10
Removing the Headlamp Lens Assembly
(Conquest Models From CB12580).................................................... ES-10
Installing the Headlamp Lens Assembly
(Conquest Models From CB12580)......................................................ES-11
Headlamp Removal (Earlier Vanguard2 & Vanguard 6x6)..............ES-11
Headlamp Installation (Earlier Vanguard2 & Vanguard 6x6)......... ES-11
Headlamp Removal
(Response, Bigfoot & Later Vanguard2 and Vanguard 6x6)............ ES-12
Headlamp Installation
(Response, Bigfoot & Later Vanguard2 and Vanguard 6x6)............ ES-12

Argo V896-65 Specifications

General

Brand	Argo
Model	V896-65
Category	Offroad Vehicle
Language	English

Summary

General Instructions

Battery

Checking the Fluid Level

Procedure for checking battery fluid levels.

Charging the Battery

Instructions for charging a vehicle battery.

Cleaning the Battery Terminals & Cable Connections

Steps to clean battery terminals and connections.

Cleaning the Battery

Method for cleaning the battery exterior.

Battery Removal

Steps to safely remove the vehicle battery.

Battery Inspection

How to inspect a vehicle battery for damage.

Battery Installation

Procedure for installing a vehicle battery.

Changing a Headlamp Bulb (Earlier Conquest Models)

Installing the Headlamp Bulb (Earlier Conquest Models)

Guide for installing a new headlamp bulb.

Removing a Headlamp Bulb

Steps to remove a headlamp bulb.

Installing a Headlamp Bulb

Procedure to install a new headlamp bulb.

Removing the Headlamp Lens Assembly (Conquest Models from CB12581)

How to remove the headlamp lens assembly.

Installing the Lens Assembly (Conquest Models from CB12581)

Guide for installing the headlamp lens assembly.

Headlamp Removal (Earlier Vanguard2 & Vanguard Models)

Steps for removing older model headlamps.

Headlamp Installation (Earlier Vanguard2 & Vanguard Models)

Procedure to install older model headlamps.

Headlamp Removal (Response, Bigfoot and Later Vanguard2 & Vanguard Models)

How to remove headlamps on later models.

Headlamp Installation (Response, Bigfoot and Later Vanguard2 & Vanguard Models)

Procedure for installing later model headlamps.

Removing the Starter (Conquest Models)

Installing the Starter (Conquest Models)

Steps to install the starter motor on Conquest models.

Removing the Starter (Response, Bigfoot, Vanguard2 & Vanguard Models)

How to remove starter on other models.

Installing the Starter (Response, Bigfoot, Vanguard2 & Vanguard)

Procedure for installing starter on these models.

Removing the Brake Cooling Fan (Response, Bigfoot)

Installing the Brake Cooling Fan (Response & Bigfoot models)

Guide to installing the brake cooling fan.

Removing the Brake Cooling Fan (Conquest Models)

Installing the Brake Cooling Fan (Conquest models)

Procedure for installing the brake cooling fan.

Calibrating the 613-119 Digital Gauge Package