ATD Tools ATD-31170 - Installation; Adjusting Support Plate

 AYRLGRYHUH[SRVXUHWRIXPHVDQGJDVVHVWRUNLQDYHQWLODWHGDUHDDQGGRQRWEUHDWKHIXPHVUVHPHFKDQLFDOYHQWLODWLRQ
V\VWHPVWRLPSURYHDLUTXDOLW\AOZD\VXVHDQDSSURYHGUHVSLUDWRU
 WKHQZRUNLQJZLWKF\OLQGHUVDOZD\V“FUDFN”WKHF\OLQGHUYDOYHVE\VWDQGLQJWRRQHVLGHDQGTXLFNO\ RSHQLQJ DQG FORVLQJWKH
WKH YDOYH DOORZLQJ JDV WR HVFDSH FOHDULQJ WKH YDOYH RI DQ\IRUHLJQPDWHULDOIf oil or grease is found, discontinue using
the cylinder and immediately contact your supplier. 

 WKHQ DWWDFKLQJ GREEN R[\JHQ UHJXODWRUV (
QRW LQFOXGHG) WR WKH R[\JHQ F\OLQGHU RURED DFHW\OHQHUHJXODWRUVQRWLQFOXGHG)
WRWKHDFHW\OHQHF\OLQGHUPDNHVXUHWKH\DUHWLJKWHQHGLQWKHFRUUHFWGLUHFWLRQVQRUPDOO\FORFNZLVHIRUR[\JHQDQGFRXQWHU
FORFNZLVHIRUDFHW\OHQH)
Unpacking
:KHQXQSDFNLQJFKHFNWRPDNHVXUH\RXKDYHDOOWKHSDUWVOLVWHGRQWKHIROORZLQJSDJH
Warning :KHQ FRQQHFWLQJ PDNH VXUH \RX FRQQHFW 5E' DFHW\OHQH KRVHV ZLWK QRWFKHV(OHIWKDQGHGWKUHDGV)WRWKH
FRQQHFWLRQVZLWKQRWFKHV(OHIWKDQGHGWKUHDGV)CRQQHFWWKHG5EE1R[\JHQKRVHVZLWKRXWQRWFKHVWRWKHFRQQHFWLRQVZLWKRXW

QRWFKHV6HH FIGURE 1 
BE SURE TO USE TEFLON (PTFE) TAPE ON ALL
FITTINGS. THIS TAPE IS SUPPLIED WITH THE UNIT. FAILURE
TO USE THIS TAPE WILL RESULT IN GAS LEAKS AND POTENTIAL EXPLOSIONS, FIRES, AND HEALTH PROBLEMS
INCLUDING DEATH.
Installation
6HHFIGURE 2DQGWKH$VVHPEO\'UDZLQJRQWKHODVWSDJH
Note)RUFHLOLQJ PRXQWLQJPRXQWWKH +RVH5HHOKLJKHQRXJK DERYHWKHIORRUWR DYRLGFRQWDFWZLWKSHRSOHDQGHTXLSPHQW
 BHIRUHDWWDFKLQJWKH%DVHWRDZDOORUFHLOLQJPDNHVXUHWKHPRXQWLQJVXUIDFHLVFDSDEOHRIVXSSRUWLQJWKHZHLJKWRIWKH
+RVH5HHODQGKRVHDQGFDQZ
LWKVWDQGWKHVWUHVVRISXOOLQJDQGUHWUDFWLQJWKHKRVH
 7KH6XSSRUW3ODWH(#PD\EHDGMXVWHGVRWKDWWKH+RVHV(#)OHDYHWKH5HHOVRQHLWKHUVLGH
To change its position:
D 3XOORXWVRPHKRVHDQGOHWWKHUHHOODWFK(FOLFNDQGVWRS)
E 5HPRYHWKHBROWV(#WKDWKROGWKH6XSSRUW3ODWHLQSODFH
F) 5RWDWHWKH6XSSRUW3ODWH(#)LQWRWKHFRUUHFWSRVLWLRQ5HSODFHWKH%ROWV(#)DQGWLJKWHQ
Acetylene
Air Fitting (inlet) (42)
Notch
Oxygen Air Fitting
(outlet) (45)
Notch
Oxygen Air
Fitting (inlet) (45)
Acetylene Air
Fitting (outlet) (42)
RED
GREEN
GREEN
RED
FIGURE 1