SeServrvicice / e / SpSpececififiic ic insnsttruructctiionons / s / StStororagage e of of mamachchinines es anand md mototoorsrs 3.3.1919
ATLET SERVICE MANUAL A-ERGOATLET SERVICE MANUAL A-ERGO
Specific instructionsSpecific instructions
Storage of machines and motorsStorage of machines and motors
Machines in storage that wiMachines in storage that will not to be used within a month, must be given special ll not to be used within a month, must be given special attentionattention
so that problems do not occur when they are to be used again. Dust, dirt, condensation andso that problems do not occur when they are to be used again. Dust, dirt, condensation and
moisture that occurs during large variations in temperature, as well as problems with rustmoisture that occurs during large variations in temperature, as well as problems with rust
and oxidisation, must be prevented. Motors should therefore be protected with waxedand oxidisation, must be prevented. Motors should therefore be protected with waxed
paper or the equivalent, and also with a moisture absorbing material.paper or the equivalent, and also with a moisture absorbing material.
Drive motorDrive motor
Preventive maintenancePreventive maintenance
Preventive maintenance is implementePreventive maintenance is implemented in accordance with the intervals set out in d in accordance with the intervals set out in thethe
service chart.service chart.
HoweverHowever, in , in some cases exceptions must be made and some cases exceptions must be made and the intervals shortened, dependingthe intervals shortened, depending
on local conditions in customer premises, on local conditions in customer premises, e.g. a rugged environment with dust, highe.g. a rugged environment with dust, high
humidity levels, and salt, etc.humidity levels, and salt, etc.
•• LisListen foten for abnr abnormormal noal noise ise frofrom thm the beae bearingrings whs when then the moe motor itor is runs run. Ch. Chececk thak that itt it
does not vibrate abnormally.does not vibrate abnormally.
•• Blow Blow cleaclean thn the mote motor wior with dth dry cry compompresressed ased air or cir or clealean witn with a vah a vacucuum clum cleaeanerner. A. A
special cleaning fluid should be used to drive out oil and dirt, if oil has leaked fromspecial cleaning fluid should be used to drive out oil and dirt, if oil has leaked from
the gearbox into the the gearbox into the motor, see section 2. Finallymotor, see section 2. Finally, blow dry , blow dry with compressed air.with compressed air.
•• CheCheck thck the inse insululatiation reon resissistantance foce for the mor the mototor, ser, see spe speciecificficatiation in son in secectiotion 1 forn 1 for
correct value.correct value.
To Next Page
Loading...