55..66 DDrriivve e uunniit t / / RReeppaaiir r iinnssttrruuccttiioonns s / / GGeeaarrbbooxx
ATLET SERVICE MANUAL A-ERGOATLET SERVICE MANUAL A-ERGO
per or the equivalent, and also with a moisture absorbing material, and stored indoors atper or the equivalent, and also with a moisture absorbing material, and stored indoors at
room temperature, preferably in a cardboard box.room temperature, preferably in a cardboard box.
GearboxGearbox
Oil change, gearboxOil change, gearbox
1.1. If oil nIf oil needs teeds to be do be drainrained ofed off this f this is dis done thone through rough the pluthe plug in g in the bothe bottom ottom of thef the
gearbox, pos. 1 figuregearbox, pos. 1 figure 5.15.1
2.2. Oil iOil is fs filleilled eid eithther ther throrough ugh the the pluplug, pg, pos. os. 2 fi2 figurguree 5.15.1, or by , or by dismantling the motor.dismantling the motor.
3.3. The oiThe oil shol should liuld lie at the e at the same same level level as thas the hole e hole by the by the screwscrew, pos, pos. 2 fig. 2 figureure 5.15.1. Fill. Fill
with oil until the oil starts to run out from the hole.with oil until the oil starts to run out from the hole.
A suction spray is recommend to simplify filling via pos. A suction spray is recommend to simplify filling via pos. 2.2.
Dismantling and assembling the gearboxDismantling and assembling the gearbox
00
00
1.1. BlocBlock up the trk up the truckuck. The dr. The drive whive wheel sheel should ruould run free, an free, appropprox. 30 cm ax. 30 cm abovbove the floe the flooror..
2.2. LoosLoosen the cen the cablable conne connectioections to thns to the drive me drive motorotor, serv, servo motoo motorr, elec, electric brtric brake anake andd
wheel indicators. Label the cables that are not labelled to ensure correct reassembly.wheel indicators. Label the cables that are not labelled to ensure correct reassembly.
3.3. DiDismsmanantltle e ththe me mototoror, s, seeee “Drive motor”, page 5.4“Drive motor”, page 5.4
4.4. LoosLoosen the en the 6 sock6 socket heet head caad cap screp screws on ws on the bothe bolted jolted joint bint between etween the mothe motor btor bed aned andd
chassis.chassis.
5.5. LowLower der down town the ghe gearearbox fbox from trom the mahe machichine wine with gth greareat caret care..
Note!Note!
All the bolts and screws are tightened to the tightening torque specified in All the bolts and screws are tightened to the tightening torque specified in the tablethe table
in section 1.in section 1.
6.6. DraDrain in ththe oe oil il frofrom tm the he gegeararbobox, x, seseee “Oil change, gearbox page 5.6”“Oil change, gearbox page 5.6”..
Figure 5.1Figure 5.1
GearboxGearbox
05_001_A-Ergo_vxl da.eps
05_001_A-Ergo_vxl da.eps
11
22
To Next Page
Loading...