Atwood RA - User Manual

£Atwood
LITERATURE NUMBER 52229
LP GAS RANGE &
SLIDE-IN COOKTOPS
Atwood Mobile Products LLC
1120 North Main Street • Elkhart,lN 46514
PHONE:574·264·2131 FAX:574·262·2550
INTERNET: http://www.atwoodmobile.com
RA, CA, RV, CV (35) Models
PROTECTED BY U.S. PATENTS 0397,909 AND 5,931,151
OTHER PATENTS PENDING
ENGLISH
avoid possible
injury or death
SAFETY ALERT SYMBOLS
Safety Symbols alerting you to potential personal safety hazards.
Obey all safety messages following these symbols.
& WARNING
& CAUTION
avoid possible
injury and/or property damage
FOR YOUR SAFETY
READ ALL INSTRUCTIONS BEFORE OPERATING APPLIANCE
Installer: Provide these instructions to the consumer.
Consumer: Keep documents for future reference.
& WARNING
FIRE OR EXPLOSION
FOR YOUR SAFETY
WHAT TO DO IF YOU SMELL GAS
• Open windows.
• DO NOT touch any electrical switch, or use any phone or radio
vehicle.
• Extinguish any open flame.
• Evacuate ALL persons from vehicle.
• Shut off gas supply at gas container or source.
• DO NOT start vehicle's engine or electric generator.
• Contact nearest gas supplier or qualified Service Technician <or
repairs.
• If you cannot reach a gas supplier or qualified Service TE3Cf''' an,
contact the nearest fire department.
• DO NOT turn on gas supply until gas leak(s) has been reoareo.
FOR YOUR SAFETY
~ DO NOT store or use gasoline or other flammab e ape'S an Ids
in the vicinity of this or any other appliance.
& WARNING
• Improper installation, adjustment, service 0
cause injury, property damage or death. 8ifer' --
assistance or additional information. co • a
service agency, manufacturer or the gas sc
& WARNING
EXPLOSION OR FIRE
• Shut off all gas appliances and pilot lig's -
tanks, LP tanks or when vehicle is in ot -
• Atwood & Wedgewood gas operated coo -_ a:::::: 2.-= are for
use with LP gas only, and for installa '0 er _ es
only (e.g. travel trailers, motor homes. e •
& WARNING
CARBON MONOXIDE POISO
• DO NOT use cooking appliance for space • s a
danger to occupants of vehicle and car- !1c-- -~r'f
components of the range/cooktop.
• A window or air vent should be oper s g-'
cooking appliance. Gas flames co s ,...,,,,_ -=.-
replaced to assure proper cornbusnor
-Installation -Operation -Maintenance
Effective 8/04/10
NOTE TO CONSUMER:
Have the installer or dealer show you where the main gas shut off
valve is located so that you will know how and where to turn off the
gas supply when necessary.
Table of Contents
Safety Information 1
Installation 1-2
Operation 2-3
Maintenance 3-4
Storage 4
Covers .4
Illustration Figures 5
Warranty 5
Parts Identification 7-8
Accessories / Extended Warranty 15
Cabinet & Counter/Recessed Bi-Fold - Cut Out Charts 6
Wiring Diagram 6
INSTALLATION
Installation must conform with local codes or in the absence of local
codes, wi h the American National Standard for Recreational Vehicles,
ANSVA 19.2 and Article 551, ANSI/NFPA 70. In Canada, installation
must con orm with CSA Z240.4.2-M.
& WARNING
FIRE, EXPLOSION, BURN INJURY
CARBON MONOXIDE POISONING
• The cooking appliance must be completely separated and/or
sealed from other air moving or air consuming devices such as,
bu not limited to, furnaces, microwave ovens, clothes dryers,
cooling fans and doors or drawers in common cabinets. Failure
to do so will affect the appliance(s) combustion air supply by
creating either a negative or positive draft.
• EGATIVE DRAFT caused by air moving appliances may draw
he IOp burner flame down into or toward the cooktop resulting
in coo op damage, burn hazard, explosion possibility and/or
carbo monoxide buildup.
, • POSITNE DRAFT may blowout the top burner flame during use
resu ing in an explosion and/or fire hazard and/or injury to the
occupan s of the vehicle.
• DO - operate the appliance in excessive windy conditions as
this may cause a negative or positive draft.
1. For proper operation of your cooking appliance:
'T"'-lE HOUSING CABINET MUST BE:
• properly constructed.
• sq ared to the countertop and cabinet face
OP:: G IN THE HOUSING CABINET MUST BE:
• e e from side to side and front to rear
es. he cabinet opening must be constructed so that no
_ e material can be placed next to the range sides. If there is
een the range and an adjacent cabinet, the gap must be
'0 installing the range.
& WARNING
FIRE
- r-es is the minimum vertical distance to combustible
~-a-e a aoove the cooktop stove. This distance may be reduced
o _ on-combustible construction in accordance with Table
2-6.-2 SI A119.2.
1

Summary

Safety Alert Symbols

Warning and Caution Symbols

Symbols alerting to potential personal safety hazards.

General Safety and Operation

Gas Leak, Refueling, and CO Prevention

Procedures for gas leaks, refueling, and carbon monoxide prevention.

Installation Requirements

Cabinet, Clearance, and Airflow

Cabinet construction, clearances, and airflow management for installation.

Installation Procedures

Cabinet Prep, Gas, and Electrical Connection

Preparing cabinets, making gas and electrical connections.

Leak Testing and Range Top Replacement

Checking for gas leaks and replacing the range top.

Top Burner Operation

Burner Safety and Lighting Instructions

Burner safety precautions and lighting instructions for match, spark, or electronic ignition.

Burner Settings and Oven Operation

Burner Settings and Cookware Advice

Burner setting guide and cookware selection advice.

Oven Safety and Lighting Procedures

Oven safety warnings and procedures for lighting pilot and burner.

Maintenance Procedures

Cleaning Safety and Surface Care

Safety precautions and recommendations for cleaning appliance surfaces.

Maintenance and Care Instructions

Range Top Removal and Storage

Instructions for range top removal and appliance storage guidelines.

Cooktop Care and Oven Use Guidelines

Porcelain care, cookware selection, and oven preheating/airflow.

Limited Warranty Information

Coverage, Claims, and Implied Warranties

Details on warranty coverage, claims, and implied warranties.

Cut Out Charts and Diagrams

Cabinet Dimensions and Cover Cut Outs

Tables for cabinet dimensions and recessed bi-fold cover cut outs.

Wiring and Mounting Information

Electronic ignition schematic and range hood mounting details.

Model Parts Identification

RA & CA and RV & CV Model Parts

Identification of parts for RA/CA and RV/CV model series.

Part Number Listings

Wedgewood and Atwood Model Part Numbers

Listed part numbers for Wedgewood and Atwood models.

Atwood RA Specifications

General

Brand	Atwood
Model	RA
Category	Ranges
Language	English