EasyManua.ls Logo

BIG RED JACKS T88007 - User Manual

BIG RED JACKS T88007
31 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
OWNER’S MANUAL
7 GALLON AIR TANK
Questions, problems, missing parts? Before returning to your retailer, call our customer service department at
1-888-44-TORIN (1-888-448-6746), 8 a.m.- 5 p.m., PST, Monday-Friday.
Read carefully and understand all ASSEMBLY AND OPERATION INSTRUCTIONS before operating. Failure
to follow the safety rules and other basic safety precautions may result in serious personal injury.
Item.: T88007
04182017Version

Table of Contents

Questions and Answers

  • L
    lisabradleyJul 28, 2025
    Why is my BIG RED JACKS T88007 tank losing air pressure?
    • B
      billy99Jul 28, 2025
      There are several potential reasons why your tank might be losing air pressure: * Air leaks: Use mild soapy water to locate the leak. * Dirty air chuck: Clean dirt from the air chuck, and close the hose shutoff valve before replacing the hose assembly. * Damaged hose: Replace the hose assembly. * Loose hose connection: Remove the hose, apply thread sealant, and tighten the fitting. * Damaged gauge: Replace the gauge. * Loose gauge connection: Remove the gauge, apply thread sealant, and tighten it. * Damaged manifold or defective relief valve: Replace the manifold. * Loose manifold connection: Remove the manifold, apply thread sealant, and tighten it. * Pin hole from internal rusting: Replace the tank.
  • J
    Jessica SummersAug 2, 2025
    What to do if I cannot get air out of my BIG RED JACKS T88007 Storage tank?
    • V
      Valerie CoxAug 3, 2025
      If you're unable to get air out of your tank, here are a few things to check: * Low tank pressure: The tank pressure needs to be higher than the tire pressure. Increase the tank pressure. * Hose shutoff valve closed: Turn the red knob on the manifold counterclockwise to fully open it, about 1-1/2 turns. * Damaged air chuck: Replace the hose assembly.
  • A
    Angela HallAug 10, 2025
    Why does my BIG RED JACKS T88007 tank fill slowly?
    • J
      Jessica LeeAug 10, 2025
      A slow-filling tank can be due to a couple of reasons: * Fill valve obstructed or damaged: Inspect the opening for any foreign material. Clean or replace the valve if necessary. * Low volume air output source: Locate a compressed air source of 85 to 125 psi.
  • D
    Danny CooleyAug 15, 2025
    What to do if there is water in my BIG RED JACKS T88007 Storage tank?
    • J
      jamessimsAug 15, 2025
      If you find water in your tank, it's likely due to a contaminated compressed air source. Drain the water from the tank; refer to the maintenance section for instructions.
  • J
    Jonathon GatesAug 21, 2025
    Why will my BIG RED JACKS T88007 Storage tank not hold enough air?
    • D
      Dawn Cain MDAug 21, 2025
      If your tank isn't holding enough air, it could be due to: * Gauge not reading correctly: Check the air pressure at the fill stem using a tire pressure gauge. * Compressed air source below 85 psi: If the gauge reads differently, replace it and locate a compressed air source of 85 to 125 psi.

Summary

Register Your Product

Important Product Information

Product Registration Details

Record model name, number, manufacture, and purchase date for future reference.

Owner; User Responsibility

Intended Use

Portable air tanks for emergency tire inflation and recreational uses for home, farm, and auto.

Technical Specifications

General Safety Rules

Important Safety Considerations

Understand conditions, situations, and use common sense for safe operation.

General Safety Instructions

Do not alter safety valve, discard by date, no repairs, no liquids, drain condensation, never drop.

Safety Markings and Warnings

Do not exceed 125 PSI, overfilling is dangerous, fill from low pressure sources, use dryer.

Unpacking and Initial Inspection

Operation Guide

Maintenance Instructions

Pre-Use Inspection

Inspect for damage, wear, broken/missing parts, and proper function before each use.

Worn Parts, Rust, and Dirt

Rusty components or worn parts can cause improper function; stop use if issues arise.

Air Hose Maintenance

Weathered or leaking air hoses can affect safe operation; stop use and contact service.

Cleaning Procedures

Clean obstructed parts when tank is empty; do not use motor oil for lubrication.

Rust Prevention

Check daily for signs of rust or corrosion and clean as needed.

Storing the Equipment

Store in a dry, indoor location away from damage, extreme temperatures, or chemical environments.

Water Moisture Maintenance

Draining Instructions

Drain tank outdoors, hold upside down, open valve to release air and moisture.

How to Replace Manifold Assembly

Assembly Diagram and Parts

Troubleshooting Guide

Warranty Notice

Torin One Year Limited Warranty

BIG RED JACKS T88007 Specifications

General IconGeneral
BrandBIG RED JACKS
ModelT88007
CategoryStorage
LanguageEnglish