39 S450 Operation & Maintenance Manual
MACHINE SIGNS (DECALS) (CONT’D)
Pictorial Only Safety Signs (Cont’d)
19. Service Checklist And Schedule (7205727)
This safety sign is located inside the rear door (tailgate).
AVOID INJURY OR DEATH
• Keep door / cover closed except for service.
• Keep engine clean of flammable material.
• Keep body, loose objects and clothing away from
electrical contacts, moving parts, hot parts and
exhaust.
• Do not use the machine in space with explosive
dusts or gases or with flammable material near
exhaust.
• Never use ether or starting fluid on diesel engine
with glow plugs or air intake heater. Use only
starting aids as approved by engine
manufacturer.
• Leaking fluids under pressure can enter skin and
cause serious injury.
• Battery acid causes severe burns; wear goggles.
If acid contacts eyes, skin, or clothing, flush with
water. For contact with eyes, flush and get
medical attention.
• Battery makes flammable and explosive gas.
Keep arcs, sparks, flames and lighted tobacco
away.
• For jump start, connect negative cable to the
machine engine last (never at the battery). After
jump start, remove negative connection at the
engine first.
• Exhaust gases can kill. Always ventilate.
W-2782-0409
This machine is factory equipped with a spark
arrester exhaust system that must be maintained for
proper function.
• WITH MUFFLER
The muffler chamber must be emptied every 100
hours of operation to keep it in working
condition.
• WITH DIESEL OXIDATION CATALYST (DOC)
Do not remove or modify the DOC.
• WITH DIESEL PARTICULATE FILTER (DPF)
The DPF must be maintained according to the
instructions in the Operation & Maintenance
Manual for proper function.
(If this machine is operated on flammable forest,
brush or grass cover land, a spark arrester attached
to the exhaust system may be required and must be
maintained in working order. Refer to local laws and
regulations for spark arrester requirements.)
I-2350-EN-0813
To Next Page
Loading...