Home
Bristol Babcock
Control Unit
3310 Series
Bristol Babcock 3310 Series User Manual
5
of 1
of 1 rating
404 pages
Give review
Manual
Specs
To Next Page
To Next Page
Loading...
www.EmersonProcess.com/Bristol
Instruction Manual
CI-3310
Nov., 2006
RTU 3310
Remote Terminal Unit RTU 3310
2
Table of Contents
CI-3310 -
9
Table of Contents
9
General Overview
17
Hardware Structures
19
Circuit Overview
21
EX-Based CPU Engine Boards
23
I/O Modules
24
Solid State DC Relay Discrete Output Module
25
Hazardous Area Classification
26
Categories of Application Software
27
Supervisory Software
30
System Applications
31
Stand-Alone Unit
32
Wide Area Network (WAN)
34
Environmental Considerations
35
ESDS (Electrostatic Discharge Sensitivity) Considerations
36
Installing Units
38
Installing Nema-4 Enclosures
40
Optional Communications Receptacle
41
Plug-In I/O Termination
42
General Notes
43
Preventing MIX-Ups of Terminal Block Connectors
45
Description
47
Watchdog Terminals
50
Board Operation
51
COMMUNICATION PORT SWITCHES, JUMPERS and Leds
52
Leds
53
Description
55
Switch SW2 (Node Address)
60
Jumper W2 (Numeric Processor)
61
Leds and Reset Button
62
Low Byte and High Byte Matched Set
63
Description
65
I/O Interface
67
Switch and Jumper Configuration
68
Switches SW1 -5, -6 - ACCOL FLASH Lock/Accol Load Storage
69
Switches SW3 & SW4
70
Description
71
Protected Mode 32 Bit Cpu Engine I/O Interface
74
Switches SW1 -2, -3, -4 - Cold Download Baud Rate
76
Bit CPU Eng. Board Switches SW1-6 - ACCOL Load Storage SW1-4 - ACCOL FLASH Lock
77
Bit CPU Engine Board Switch SW2 - (Node Address)
78
Bit CPU Engine Board Reset Button SW5
79
Cpu Engine Assembly Number Assignments
80
General
81
Signal Grounding Options
86
V Type Modules
87
V / 4-20 Ma TYPE MODULES
88
Ma Transmitter Using +24 V DPC Power Source
89
Ma Transmitter Using Auxiliary +24 V Power Supply
90
Specifications
91
Environmental Specifications
92
General
93
SELECTING 1-5V or 4-20 Ma INPUTS
95
Ma Transmitter Using +24 V DPC Power Source
96
Ma Transmitter Using Auxiliary +24V Power Supply
97
General
99
SELECTING 1-5V or 4-20 Ma INPUTS
102
Ma Transmitter Using +24V DPC Power Source
103
Ma Transmitter Using Auxiliary +24V Power Supply
104
Specifications
105
Environmental Specifications
106
General
107
Signal Grounding Options
110
V / 4-20 Ma TYPE MODULES
111
Ma Output
112
Specifications
113
General
115
SELECTING 1-5 V or 4-20 Ma OUTPUTS
117
Ma Output
118
Jumpers & Adjustments
119
Environmental Specifications
120
General
121
Jumper Locations
126
Applications for 5, 12 & 24 V Type Modules
127
Relay Contact or PDM Xmtr. as Input
128
Applications for 120 V Type Modules
129
Specifications
130
Environmental Specifications
131
General
133
LED On-Off OPTION - Jumper W17
135
Internally-Sourced Relay Contact or Open Collector DI
136
Driven Differential Relay Contact DI
137
Module Restrictions
138
General
139
LED On-Off Option
143
Open Collector/Open Drain Type Modules
144
Specifications
146
Environmental Specifications
147
General
149
Terminal Designations
151
The External Circuit
152
Open Drain Output Requirements
155
General
157
Terminal Designations
158
Signal Grounding Options
159
Hsc Input Configurations
160
Configurations for HSC-Powered Devices (Non-Isolated
161
Specifications
166
General
167
Terminal Designations
168
Signal Grounding Options
170
Hsc Input Configurations
171
Configurations for Self-Powered Devices (Isolated)
172
Specifications
177
General
179
Four-Wire Rtd Input
181
Three-Wire Rtd Input
182
Thermocouple or Millivolt Input
183
Environmental Specifications
184
General
185
Hsai Module Terminal Designations
187
Hsai Module Signal Grounding Options
188
AI Grounding
189
DI Grounding
190
Ma Transmitter Using Auxiliary +24 V Power Supply
191
Hsai Module Discrete Input Wiring
192
Hsai System Overview
193
HSAI Panel Jumpers & Leds
195
HSAI Panel Terminal Blocks
196
Specifications
198
HSAI Module Input Impedance
199
HSAI Panel Common Mode Voltage
200
Description
201
Configuration of Cbo Module
205
Connections for Open Collector Termination Boards
206
Wiring of +24 V Supply Terminals
207
Service
208
General
211
Starting the Rtu
212
Shutdown Procedure
215
Troubleshooting Hints
222
Status Leds
223
DI/Do Failures
227
High Speed Counter Module Tests
228
Disconnecting RAM Battery
229
Mfib Service and Diagnostics
231
Power Supply Output Voltage Test
232
Mfib Board Checks
235
TXD and RXD Leds
236
Power Section
237
Cpu & Analog Input Module Performance Specifications
238
Analog Output Module Performance Specifications
239
Discrete Input Module Performance Specifications
240
Thermocouple Accuracy
242
High Speed Counter Module Performance Specifications
243
Environmental Specifications
244
TYPICAL POWER REQUIREMENTS @ 24Vdc
245
Contents / 2
331
Pip-Cw_10 Upgrade Kit Hardware Installation Guide
332
Section 7 - Windiag Diagnostics
364
Diagnostics Using WINDIAG
365
Communication Diagnostic Port Loop-Back Tests
366
Serial Comm. Port External Loop-Back Test Procedure
366
Section 8 - Cw_10 Specifications
368
CW_10 CPU Board Specifications
368
CPU Board Communication Port Specifications
368
CPU Board 3.3V Power Supply Specifications
368
CPU Board Environmental Specifications
369
CW_10 Multi-Function Interface Board (MFIB) Specifications
369
MFIB Board Connectors
369
MFIB Board Communication Port Specifications
369
MFIB Board Power Supply Specifications
369
MFIB Board Environmental Specifications
370
Material Safety Data Sheets
371
Description
381
DPC-3330 Boards
381
RTU-3310 Boards
381
Model 3508 Transmitter Operation
381
Model 3808 MVT Transmitter Operation
381
Configuration & Wiring
383
Wiring Connections
383
Transmitter Interface Board Jumper Configuration
384
Led Indicators
384
Specifications
384
Tib
384
Tib
385
Appendix Tt
387
Description
387
Cable Connections
389
Field Wiring Connections
389
Transmitter Setup & Configuration
389
Led Indicators
391
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Bristol Babcock 3310 Series and is the answer not in the manual?
Ask a question
Bristol Babcock 3310 Series Specifications
General
Brand
Bristol Babcock
Model
3310 Series
Category
Control Unit
Language
English
Need help?
General
To Next Page