Broseley eVolution - Maintenance; Health and Safety Precautions (RCF); Cleaning the appliance; Fuel Bed Ceramics Care


eVo5MS07‐11  08/07/2011

Trouble‐Shooting


1. Smokecomesoutofthestovewhentheloadingdoorisopened.

• Thechimneycavityintowhichthe125mmfluepipehasbeeninstalledmaybelessthan
theminimumrequirement.
• Deposits(soot)mayhavebuiltupinthechimneyandberestrictingtheflowofwaste

products.Thisflowrateisknownasthe‘draw’.

2. TheStovedoesnotproducetheexpectedheatintotheroom.

• Hasthefluepipebeense aledtothechimneytopreventheatbeingdrawnupthe
chimneytowaste?
• Greenorwetwoodisbeingburnt.
• Thechimneyhasexcessivedraw(thisisunusual).Seekinstalleradvicewithregard
toinstallingaFlueDraughtStabiliser.
• Thestovehasbeenrecessedintotheexistingfireplaceandalotofheatisabsorbed
bethesurroundingfireplacewallsratherthanbeingradiatedintotheroom.Pullthe

stoveforward.
• Forthemaximumefficiencyofheattransferenceintotheroomthestoveshouldbe
sitedonthehearthofthefireplaceratherthanrecessed.

3. TheStoveburnstoofast.

• Usewholelogsratherthansplitones.
• Thewoodbeingusedmaybegenerally
toosmall.
• The“air‐tight”sealbetweenthefibreropeonthe doorsandthecastingmayhavebeen
lost,adjustdoorhandlelocknutstoreinstatethisseal.
• Thechimneyhasexcessivedraw(seekinstallersadviceonthispoint).
• Thefibreropesealbetweenthedoorand
theglassmaybeleaking.Tightenorreplace.
• Theglassisnotsealed,gentlytightenglassretainingclips.Donotovertightenasthiswill
stressorbreaktheglass.
• Thefibreropeondoorsandglasshaswornout.Replace.
• 

4. TheCastingsdonot
lineup

• Thereareseveralpositionsonthesidecastingstoallowadjustmentifthecastingsdo
notlineupcorrectly.Byusingsmallrotationsadjustthescrewsattachedtothesideto
suitthedesireddistanceneeded.

•
Ensurethebaseisattachedcorrectlyandorlinesuptothesidecastingsbefore
tighteningfully.

