Burstner Ixeo TL IT 640

Questions and Answers

L
loripowellAug 16, 2025
What to do if my Burstner Ixeo TL IT 640 Motorhomes living area battery is overloaded ('hot')?
- J
  Joshua JohnsonAug 17, 2025
  If the living area battery in your Burstner Motorhomes is overloaded or 'hot', consider these steps: * Check the battery selection switch and move its position if it is set wrongly. * Ensure the battery cut-off switch on the transformer/rectifier is switched on. * If the living area battery is discharged, charge it. * Inspect the jumbo flat fuse (50 A) on the living area battery and replace it if it is defective.
A
Anna MclaughlinAug 19, 2025
Why is my Burstner Ixeo TL IT 640 Motorhomes air conditioning unit not starting up?
- A
  andrewayersAug 20, 2025
  The air conditioning unit in your Burstner Motorhomes might not start due to several reasons: * There is no 230 V power supply. Connect the vehicle to the local power supply. * The 230 V automatic circuit breaker has triggered. Switch on the 230 V automatic circuit breaker. * The remote control batteries are empty. Change the remote control batteries. * There is an obstacle between the remote control and the IR receiver. Remove the obstacle. * The temperature has been set incorrectly. Adjust the temperature.
H
Harry Cline MDAug 22, 2025
What to do if road light system or interior lighting does no longer work correctly in my Burstner Motorhomes?
- J
  jesus73Aug 22, 2025
  If the road light system or interior lighting in your Burstner Motorhomes is not working correctly, it could be due to several reasons: * A bulb is defective. Replace the bulb, noting the volts and watts specifications. * The fuse on the transformer/rectifier is defective. Replace the fuse on the transformer/rectifier.
S
stevenhillAug 25, 2025
What to do if my Burstner Motorhomes heater does not ignite?
- T
  tara64Aug 26, 2025
  If the heater in your Burstner Motorhomes does not ignite, check the following: * Ensure there is enough gas by opening the regulator tap and gas isolator tap. * Check the battery voltage and charge the battery if it is too low. The heater should switch on automatically if the battery voltage rises above 11 V. * Verify that there is a 230 V power supply and connect it if necessary.
R
rtuckerAug 27, 2025
What to do if I have no gas in my Burstner Motorhomes?
- B
  blairandreaAug 27, 2025
  If you have no gas in your Burstner Motorhomes, check the following: * Ensure the gas bottle is not empty; change it if needed. * Make sure the gas isolator tap is open. * Check that the regulator tap on the gas bottle is open.
T
Tami MooreAug 30, 2025
What to do if the 12 V indicator lamp does not light up or the extractor hood does not work in my Burstner Ixeo TL IT 640 Motorhomes?
- D
  Devon MurrayAug 30, 2025
  If the 12 V indicator lamp does not light up or the extractor hood does not work in your Burstner Motorhomes, try the following: * Ensure the 12 V power supply is switched on. * Check that the battery cut-off switch on the transformer/rectifier is on. * Charge the starter or living area battery if they are not charged. * Replace the flat fuse (2 A) in the living area battery if it is defective. * Replace the fuse (15 A) at the transformer/rectifier if it is defective.
J
jcraigSep 2, 2025
Why am I not getting a satellite signal and seeing a black screen on my Burstner Ixeo TL IT 640 Motorhomes?
- H
  Heather FordSep 2, 2025
  If you're experiencing a black screen and no satellite signal in your Burstner Motorhomes, it could be due to a few reasons: * Ensure that there are no obstacles in front of the satellite unit towards the south. * Verify that the correct satellite has been selected.
H
Hannah WatsonSep 4, 2025
Why won't my Burstner Ixeo TL IT 640 Motorhomes satellite unit switch on?
- J
  Jacqueline Green DVMSep 5, 2025
  The satellite unit in your Burstner Motorhomes might not switch on if: * The vehicle engine is running. Switch the vehicle engine off. * The remote control battery is empty. Change the battery. * The fuse on the supply cable is damaged. Replace the fuse.
K
Kathryn PhillipsSep 7, 2025
What to do if I find leakage water inside my Burstner Ixeo TL IT 640?
- M
  Melinda GonzalezSep 7, 2025
  If you find leakage water inside your Burstner Motorhomes: * Identify and fix the leak, and re-connect any loose water pipes. * Replenish drinking water if the water tank is empty. * Ensure the drain cock is closed.
T
Thomas NewmanSep 10, 2025
Why is my Burstner Motorhomes microwave oven not cutting in?
- M
  Melissa CharlesSep 12, 2025
  If the microwave oven in your Burstner Motorhomes is not working, check the following: * Replace the fuse if it is defective. * Ensure the door of the microwave oven is properly closed, removing any obstructions.

Summary

Safety

Fire prevention

Instructions to avoid fire risks and hazards.

Fire-fighting

Procedures and equipment for fire suppression.

In case of fire

Immediate actions to take during a fire incident.

Road safety

Crucial instructions for safe driving and vehicle handling.

Water system

Procedures for safe water system operation and winterization.

Before the journey

Payload

Guidance on calculating and managing vehicle load capacity.

Calculating the payload

Step-by-step guide to determining the vehicle's payload.

Loading the vehicle correctly

Instructions for distributing load evenly for optimal driving characteristics.

Towing

Critical safety advice for towing trailers and caravan couplings.

Securing add-on parts

Procedures for securing interior add-on parts and furniture flaps.

Gas regulator

Safe operation and installation of gas regulators.

During the journey

Driving the motorhome

General instructions for operating the motorhome while driving.

Driving speed

Advice on safe driving speeds and adapting to road conditions.

Brakes

Pre-journey checks and safety advice for the braking system.

Seat belts

Regulations and general advice on seat belt usage.

Child restraint systems

Safety instructions for securing children using appropriate restraint systems.

Refuelling

Safety precautions during vehicle refuelling operations.

Topping up AdBlue (Citroen base vehicle)

Pitching the motorhome

Handbrake

Correct application of the handbrake when parking.

Wheel chocks

Supports

Steady legs (special equipment)

Steady legs (AL-KO) (special equipment)

230 V connection

Refrigeration

Operation modes and safety for the refrigerator.

Awning (special equipment)

Living

External flaps

Omni-Vent skylight with fan (special equipment)

Beds

Fixed bed (gas-pressure springs)

Fixed bed (adjustable head section)

Fixed bed, hydraulic height adjustable (special equipment)

Fixed bed, height adjustable via strap system (special equipment)

Pull-down bed, electrically operated (Ixeo Time, Lyseo TD)

Operation of the electrically operated pull-down bed for Ixeo Time/Lyseo TD.

Pull-down bed at the rear, electrically operated (Lyseo TD) (special equipment)

Operation of the rear pull-down bed for Lyseo TD models.

Converting seating groups for sleeping

Conversion of semi-dinette into guest bed

Conversion semi-dinette into transverse bed (with additional cushion table)

Conversion L-seating group into transverse bed (with additional cushion table)

Conversion L-seating group into transverse bed (without additional cushion table)

Conversion L-seating group into transverse bed (Ixeo IT 680, Lyseo TD 590)

Conversion L-seating group into transverse bed (Ixeo IT 734)

Conversion semi-dinette into transverse bed (with additional cushion table and bed widening)

Conversion L-seating group into transverse bed (Ixeo IT 640)

Gas system

Gas bottles

Safe handling, transport, and connection of gas bottles.

Gas isolator taps

Operation and function of individual gas isolator taps for appliances.

Gas bottle switching facility (special equipment)

Facility without Crash Protection Unit (CPU)

Facility with Crash Protection Unit (CPU)

Changing gas bottles

Step-by-step guide for safely changing gas bottles.

Electrical system

General safety instructions

Critical safety guidelines for working with the vehicle's electrical system.

12 V power supply

Starter battery

Information on the starter battery's function, charging, and discharging.

Living area battery

Guidelines for charging, maintaining, and replacing the living area battery.

Charging batteries via a 230 V power supply

Charging batteries via the vehicle engine

Transformer;rectifier (EBL 119)

Battery cut-off switch

Battery selector switch

Battery monitor

Panel LT 96

Button for 12 V power supply

Button for water pump

Battery alarm for the living area battery

230 V power supply

230 V connection (CEE socket outlet)

Connecting the 230 V power supply

Fuses

Location, identification, and replacement of vehicle fuses.

12 V fuses

Location and replacement of 12 V fuses for various appliances.

Fuses on the living area battery

Identification and replacement of fuses near the living area battery.

Fuses on the transformer;rectifier (EBL 119)

Fuse assignments for the transformer/rectifier unit.

Fuses for the pull-down bed (Ixeo Time)

Changing fuses (Ixeo Time IT 710 - IT 734)

Fuse for the pull-down bed (Lyseo TD)

230 V fuse

Information on the 230 V fuse, including fault current protection.

Circuit diagrams, interior

Connection diagram, panel (LT 96)

Circuit diagram, exterior

Appliances

Heater and boiler

Operation and safety of the heater and boiler.

To heat properly

Hot-air heater and boiler with CP plus digital operating unit

Detailed operation of the Truma hot-air heater with CP plus unit.

Operating buttons

Functions of the buttons on the hot-air heater's operating unit.

Display

Understanding the different sections and information on the heater's display.

Carrying out settings

Switching on hot water production

How to activate the hot water (boiler) function of the heater.

Selecting gas operation

Instructions for operating the heater on gas.

Selecting 230 V electrical operation

Instructions for operating the heater on 230 V electrical power.

Selecting gas and 230 V electrical operation

Using combined gas and 230 V operation for faster heating.

Switching off the heater

Steps to turn off the heater.

Setting the rotational speed of the circulating pump

Alde auxiliary circulating pump (special equipment)

Filling;emptying the boiler

Electrical floor warming unit (special equipment)

Truma Aventa air conditioning unit

Detailed operation and features of the Truma Aventa AC unit.

Remote control

Automatic mode

Setting the desired temperature in automatic mode.

Operation and display on the unit

Manual mode

Switching on the cooling

Activating and setting the cooling mode.

Switching on the heater

Activating and setting the heating mode.

Switching on air circulation

Setting the time

Switching on the timer

Programming the switching on time

Programming the switch-off time

Deactivating the timer

Controlling Truma appliances with mobile terminal (special equipment)

Setting up the Bluetooth connection

Gas cooker

Operation and safety of the three-burner gas cooker.

Electronic ignition

Using the electronic ignition system for the gas cooker.

Gas oven (Dometic) (special equipment)

Operation and safety of the Dometic gas oven.

Microwave oven (special equipment)

Operation, safety, and cleaning of the microwave oven.

Extractor hood (special equipment)

Vented extractor hood

Recirculating extractor hood

Refrigeration

General operation and safety for the refrigerator.

Version AES

Operation of the AES refrigerator with automatic power selection.

Version MES

Operation of the MES refrigerator with manual power selection.

Change-over between energy sources

Selecting operating mode

Manual selection of the refrigerator's operating mode.

Refrigerating temperature control

Thetford N3000 E;A

Operation of Thetford N3000 E/A refrigerators.

Thetford N3000 E model

Operation of the Thetford N3000 E refrigerator model.

Thetford N3000 A model

Operation of the Thetford N3000 A refrigerator model.

230 V operation

Using the refrigerator with 230 V external power.

12 V operation

Using the refrigerator with the vehicle battery.

Gas operation

Operating the refrigerator using gas.

Thetford N97

Operation of the Thetford N97 refrigerator.

Operating modes

Overview of the Thetford N97 refrigerator's operating modes.

Switching on

Steps to switch on the Thetford N97 refrigerator.

Selecting the energy source

Manual and automatic selection of energy sources.

Setting the refrigerating temperature

Setting the desired cooling level.

Switching off

Steps to switch off the Thetford N97 refrigerator.

Refrigerator door locking mechanism

Dometic 8 series

Dometic 9 series

Thetford

Opening

Closing

Sanitary fittings

Water supply, general

General instructions for filling and using the vehicle's water supply system.

Water tank

Filling the water system

Steps for filling the vehicle's water system.

Closing;opening the overflow

Draining water (rotary handle with overflow)

Emptying the water system

Detailed steps to empty and ventilate the water system to prevent frost damage.

Waste water installation

Draining waste water

Procedure for emptying the waste water tank.

Heater for waste water tank and waste water pipes (special equipment)

Toilet

General information and safety precautions for the toilet.

Preparing toilet

Steps to prepare the Thetford toilet for use, including tank removal.

Swivel toilet

Toilet with fixed seat

Flushing

Emptying the sewage tank

Procedure for safely emptying the sewage tank (cassette).

Care

External care

General

Washing the vehicle

Interior care

Water system

Cleaning the waste water tank

Procedure for cleaning the waste water tank after each use.

Cleaning the water tank

Procedure for cleaning the fresh water tank and pipes.

Cleaning the water pipes

Steps for cleaning the internal water pipes.

Disinfecting the water system

Procedure for disinfecting the entire water system.

Cleaning the metal grease filter

Air conditioning unit (special equipment)

Maintenance and cleaning instructions for the air conditioning unit.

Winter care

Preparations

Winter operation

At the end of the winter season

Lay-up

Temporary lay-up

Winter lay-up

Starting up the vehicle after a temporary lay-up or after lay-up over winter

Maintenance

Inspection work

Requirements for regular vehicle inspections by qualified personnel.

Maintenance work

General advice on performing maintenance based on usage.

Living area battery

Extractor hood

Alde hot-water heater

Maintenance of the Alde hot-water heater system.

Checking the fluid level

How to check and top up the heating fluid level.

Topping up heating fluid

Procedure for adding heating fluid to the system.

Bleeding the heating system

Steps for bleeding air from the heating system.

Spare parts

Wheels and tyres

General

General advice on tyre care, inspection, and selection.

Tyre selection

Tyre specifications

Handling of tyres

Changing a wheel

Step-by-step instructions for safely changing a vehicle wheel.

Tightening torque

Specified tightening torques for steel and alloy wheel rims.

Tyre pressure

Importance of correct tyre pressure for safety and tyre longevity.

Troubleshooting

Air suspension (Goldschmitt)

Braking system

Safety advice for defects in the braking system.

Electrical system

Troubleshooting common faults related to the vehicle's electrical system.

Gas system

Troubleshooting common faults related to the gas system.

Truma heater;boiler with CP plus digital operating unit

Troubleshooting specific faults for the Truma heater/boiler unit.

Alde heater;boiler

Troubleshooting common issues with the Alde heater/boiler.

Air conditioning unit

Troubleshooting common faults for the air conditioning unit.

Truma

Troubleshooting common faults for the Truma AC unit.

Cooker

Troubleshooting common faults for the cooker.

Gas cooker;gas oven

Troubleshooting common faults for the gas cooker and oven.

Microwave oven

Troubleshooting common faults related to the microwave oven.

Refrigerator

Troubleshooting common issues with the refrigerator.

General faults

Common issues and remedies for the refrigerator's general operation.

Dometic MES;AES

Troubleshooting specific faults for Dometic MES/AES refrigerators.

Thetford N 3000

Troubleshooting faults indicated by error codes for Thetford N3000.

Thetford N 97

Troubleshooting faults shown by error codes on Thetford N97 LCD display.

Water supply

Troubleshooting common issues related to the vehicle's water supply system.

Pull-down bed, electrically operated (Ixeo TL)

Troubleshooting faults related to the electrically operated pull-down bed.

Inspection plan

Burstner Ixeo TL IT 640 Specifications

General

Vehicle Type	Motorhome
Model	Ixeo TL IT 640
Berth	4
Height	2.95 m
Chassis	Fiat Ducato
Transmission	Manual
Seatbelts	4
Fresh Water Tank	120 l
Waste Water Tank	90 l
Heating	Truma Combi 6
Gross Vehicle Weight	3500 kg
Engine	2.3 Multijet
Power	130 HP