C3 Technology RESIDENTIAL GAS WATER HEATERS User Manual

1
Instruction Manual
PRINTED IN THE U.S.A 0905 PART NO. 184165-003
KEEP THIS MANUAL IN THE POCKET ON HEATER FOR FUTURE REFERENCE
WHENEVER MAINTENANCE ADJUSTMENT OR SERVICE IS REQUIRED.
NOT FOR USE IN MANUFACTURED (MOBILE) HOMES
ALL TECHNICAL AND WARRANTY QUESTIONS: SHOULD BE DIRECTED TO THE LOCAL DEALER FROM WHOM THE WATER HEATER WAS
PURCHASED. IF YOU ARE UNSUCCESSFUL, PLEASE WRITE TO THE COMPANY LISTED ON THE RATING PLATE ON THE WATER HEATER.
RESIDENTIAL GAS WATER HEATERS
• For Your Safety •
AN ODORANT IS ADDED TO THE GAS USED
BY THIS WATER HEATER.
C3 Technology
®
Gas Water Heaters meet the new
ANSI Z21.10.1 standard that deals with the accidental or
unintended ignition of flammable vapors, such as those
emitted by gasoline.
GAMA certification applies to
all residential gas water
heaters with capacities of 20
to 100 gallons with input rating
of 75,000 BTU/Hr. or less.
®

C3 Technology RESIDENTIAL GAS WATER HEATERS Specifications

General

Fuel Type	Gas
Capacity	40-50 Gallons
Warranty	6-12 Years
Category	Residential
Venting	Atmospheric

Summary

Safe Installation, Use and Service

Important Definitions

Defines roles like Qualified Installer, Service Agency, and Gas Supplier for safe operation.

Introduction

Preparing for the Installation

Outlines essential steps and safety precautions before beginning water heater installation.

Typical Installation

Get to Know Your Water Heater - Gas Models

Identifies key components of the gas water heater through diagrams and labels.

Locating the New Water Heater

Facts to Consider About the Location

Provides critical points and considerations for choosing a suitable location for the water heater.

Installations in Areas Where Flammable Liquids (Vapors) Are Likely to Be Present or Stored

Warns against placing water heaters near flammable liquids due to explosion hazards.

Combustion Air and Ventilation for Appliances Located in Confined Spaces

A. All Air from Inside Buildings

Details requirements for providing combustion air from within the building for confined spaces.

Installing the New Water Heater

Water Piping

Explains the process and considerations for connecting water lines to the heater.

Venting

Vent Dampers

Discusses the use and removal of vent dampers for proper water heater operation.

For Your Information

Draft Hood Operation

Explains how to check the draft hood for proper operation during building depressurization.

Condensate

Discusses the formation of condensate, its causes, and potential issues like pilot outage.

Operational Conditions

Smelly Water

Explains causes of smelly water, often related to anode rod and water chemistry.

"Air" in Hot Water Faucets

Discusses causes of air in hot water faucets and potential solutions.

High Water Temperature Shut Off System

Describes the automatic shut-off system for high water temperatures.

Strange Sounds

Addresses common noises like sizzling and popping during heating cycles.

Periodic Maintenance

Venting System Inspection

Guides on inspecting the venting system for obstructions and damage annually.

Burner Inspection

Recommends annual inspection of the main and pilot burners.

Burner Cleaning

Provides instructions for cleaning the burner if required.

Housekeeping

Advises on regular cleaning around the water heater base.