Can-Am DS 450 2008 - User Manual

Can-Am DS 450 2008

401 pages

Save Page as PDF

To Next Page

To Next Page

Loading...

2008

Shop Manual

DS 450™

DS 450™ X

Table of Contents

Default Chapter3
- Table of Contents3
Safety Notice10
Introduction11
- General Information11
- Vehicle Information11
- Engine Emissions Information12
- Self-Locking Fasteners Procedure12
- Loctite ® Application Procedure12
- Tightening Torques16
- Manual Information17
Maintenance Chart21
- Maintenance21
- Preseason Preparation25
- Storage Procedure27
- Special Procedures29
  - Turn over29
  - Atv Immersion29
Troubleshooting31
- Technical Guidelines (Engine)31
- Diagnostic Flow Chart35
  - Fuel System35
Engine37
- Engine Removal and Installation37
- Air Intake System45
  - General46
  - Procedures46
    - Air Filter46
    - Air Filter Housing46
- Exhaust System49
  - General50
  - Procedures50
- Lubrication System53
Cooling System71
- Service Products71
- Description71
- Part Number71
- Loctite 243 (Blue)71
- General74
- Inspection74
  - Cooling System Leak Test74
- Maintenance75
  - Coolant Replacement75
- Procedures77
Magneto/Starter87
- General89
- Procedures89
Cylinder Head/Cylinder105
- General109
- Maintenance109
  - Valve Clearance109
- Inspection110
  - Cylinder Leak Test110
- Procedures111
- Crankcase/Crankshaft135
  - General137
  - Procedures137
- Clutch151
- Gearbox169
  - General172
  - Procedures172
Engine Management System181
- Overview181
  - System Description184
- Communication Tools/B.u.D.s. Software187
  - Multi-Purpose Interface-2 (Mpi-2)187
  - B.u.D.s. Software188
- Monitoring System/Fault Codes191
Fuel System199
- Electronic Fuel Injection (Efi)199
- General199
- System Description199
  - General Recommendations200
- Basic Adjustments202
- Idle Speed202
- Closed Throttle and Idle Actuator Reset202
- Procedures203
- Engine Control Module (Ecm)203
- Fuel Injector211
- Fuel Rail213
- Throttle Body215
- Throttle Body Installation217
- Throttle Position Sensor (Tps)218
- Idle Air Control Valve220
- Crankshaft Position Sensor (Cps)221
- Manifold Absolute Pressure Sensor (Maps)223
- Ambient Air Pressure and Temperature Sensor (Aapts)225
- Coolant Temperature Sensor (Cts)229
Fuel Tank/Fuel Pump231
- General233
- Inspection233
  - Fuel Tank Leak Test233
  - Fuel Pump Pressure Test234
- Procedures236
Electrical System245
Ignition System245
- General245
  - Ignition System Description245
  - Ignition System Operation245
- Troubleshooting245
  - Ignition System Testing245
- Procedures247
Charging System259
- General259
  - System Description259
- Procedures260
Starting System267
- General267
- Troubleshooting267
- Procedures268
Lights277
- General277
  - Lights System Description277
  - Lights System Operation277
- Troubleshooting277
- Lights System Testing277
- Procedures277
Drive System291
- Drive Chain/Rear Axle291
- General293
- Procedures293
Chassis303
- Wheels/Tires303
- Steering311
- Front Suspension325
- Rear Suspension337
Brakes349
- Front Brakes350
- Rear Brake351
- General352
  - System Description352
- Maintenance352
  - Brake Fluid352
- Procedures354
Body371
- Body Parts371
- General374
- Procedures374
Frame383
- General384
- Procedures384

Need help?

Do you have a question about the Can-Am DS 450 2008 and is the answer not in the manual?

Can-Am DS 450 2008 Specifications

General

Brand	Can-Am
Model	DS 450 2008
Category	Offroad Vehicle
Language	English

Related product manuals

Preview: Can-Am 2009 DS 450

Can-Am 2009 DS 450

Preview: Can-Am 2008 DS 450

Can-Am 2008 DS 450

Can-Am DS 450 X 2008

Can-Am DS 450 EFI

Preview: Can-Am DS 450 Series

Can-Am DS 450 Series

Can-Am DS 450 EFI X mx

Preview: Can-Am DS 70

Preview: Can-Am DS 90

Preview: Can-Am DS 250

Preview: Can-Am DS 250 2023 Series

Can-Am DS 250 2023 Series

Preview: Can-Am DS250