86
Maintenance Section
Magnetic Pickups - Clean/Inspect
i00906366
Magnetic Pickups -
Clean/Inspect
SMCS Code: 1907-040; 7400-040; 7400-070
g00293335
Illustration 35
Typical example
(1) Magnetic pickup
(2) Flywheel housing
g00293337
Illustration 36
Typical magnetic pickup
1. Remove magnetic pickup (1) from flywheel
housing (2). Check the condition of the end of
the magnetic pickup. Check for signs of wear
and contaminants.
2. Clean the metal shavings and other debris from
the face of the magnet.
3. Install the magnetic pickup and adjust the
magnetic pickup. Refer to the Service Manual for
the installation procedure.
i01089872
Marine Transmission Oil Level
- Check
SMCS Code: 3081-535
Check the marine transmission oil level according
to the instructions that are provided by the OEM of
the transmission or the OEM of the vessel.
For the lubrication requirements of the transmission,
refer to the recommendations on the nameplate or
the “Owner’s Manual” for the transmission.
Marine Transmission Operation,
Maintenance, Warranty, and Parts
Support
For information on maintenance and operation of
the marine transmission, consult your Caterpillar
dealer and/or the OEM dealer of the transmission.
All support for the warranty of the transmission will
be the responsibility of the OEM. All parts support
for the transmission will be the responsibility of
the OEM. This parts support includes both the
installation of parts and the resolution of any service
problems.
i01081132
Overhaul Considerations
SMCS Code: 7595-043
The following items can increase the engine service
life before an overhaul is required:
•
Use only lubricants that are recommended by
Caterpillar.
•
Follow the recommended guidelines for
maintenance.
•
Use an S·O·S Oil Analysis to determine the
maximum interval for changing the oil filter and
the oil.
•
Follow the rating definitions that are recommended
for the engine.
Repair of Piston, Ring, And Bore
As An Indicator
Investigate the piston, the ring, and the bore or
repair the piston, the ring, and the bore if one of the
following conditions occurs:
To Next Page
Loading...