CBE CB 516 - Installation; Battery Charger Installation; Cable Connections; Battery Handling and Use

180
140
85
Fig.1-DIMENSIONS(mm):
INSTALLATION
110
Fig.2-VERTICALINSTALLATION
110
197
157
IMPORTANT: -Theinstallationofthisdevicemustbecarriedoutbyspecializedtechnicians.
-Donotcarryoutanymaintenancewhenthebatterychargerisconnectedtothe
230V powersupplynet.
-
-Caution,donotconnectthebatterycharger:
whenageneratorsetwithnonstabilisedoutputvoltageisemployed
withpowermainsvoltageexceedingtheratedvalue(230V ±10%)
-Incaseofbatterycharger’smisuse,theguaranteefallsoffandthemanufacturer
declinesallresponsibilityfordamagestopeopleandthings.
1
1
BATTERY CHARGER
CABLES
-Installthebatterychargerinanappropriatehousing,dryandventilated;maximumefficiencycanbe
obtainedwhenthebatterychargerisinstalledinverticalposition(seefigure2),keepingthefrontside
atminimumdistanceof300mmandthebottomandtopsideataminimumdistanceof100mmfrom
thehousingsides.
-Donotcoverairintakes.
- Toguaranteeaproperchangeofairtheinstallationoftwoairintakes(oneplacedonthetopandone
onthebottom,seefigure2)ensuringaworkingtemperatureinsidethehousingnotexceeding50°C.
-Makesurethatthe230V safetyswitchcanbeeasilyreached.
- Theconnectiontopowersupplymainsshallbemadeinaccordancewithnationalinstallationrules.
-Beforedisconnectingthebatterychargerfrom230V powersupply,turnthesafetyswitchoff.
- Theinstallationrequiresthefixingofno.4pinsthatcanbeeasilyplacedonthe4sides.
- ThebatterychargercanbeinstalledtogetherwithCBE12Vand230Vdistributionpanels,usingthe
appropriatemodularjoints.
BATTERY
- Lead-acidbatteriesshallbepositionedinawellventilatedplace.
- Useonly12V rechargeableleadbatteries(capacity>40Ah).
- Donotuse"notrechargeable"batteries.
- Exhaustedbatteriesshallbedisposedinaccordancewithexistingenvironmentalprotectionregulations.
Warning:
-Thisapplianceisnotintendedforusebypersons(includingchildren)withreducedphysical,
sensoryormentalcapabilities,orlackofexperienceandknowledge,unlesstheyhavebeengiven
supervisionorinstructionconcerninguseoftheappliancebyapersonresponsiblefortheirsafety.
Childrenshouldbesupervisedtoensurethattheydonotplaywiththeappliance.
- Mains connection: use a 3x1.5mm² cable, type H05 RN-F or equivalent.
- Battery connection: use N07 V-K cables having adequate section (minimum section 4mm²).
- Fix the cables with the relevant blocking devices supplied.
- Protect cables from any possible damage.
7
ENGLISH