Generac
®
Power Systems, Inc. 29
ITEM PART NO. QTY. DESCRIPTION
1 0C6140 1 ASSEMB LY, E NCLOSURE BASE
0D1901 1 ASSEMB LY, E NCLOSURE BASE (7KW)
2 0C6735 2 SUPPORT, ROOF FOLDING
3 0C7061 1 ENCLOSURE, FRONT
4 0C7062 1 ENCLOSURE, EXHAUST SIDE
0C7062A 1ENCLOSURE, EXHAUST SIDE (7KW)
5 0C7063 1 ENCLOSURE, SIDE & BACK
0C7063A 1ENCLOSURE, SIDE & BA
CK (7KW)
6 0C7064 1 ENCLOSURE, ROOF
7 0C7065 1 PANEL, ALTERNATOR DIVIDER
0C7065A 1PANEL, ALT E RNATOR DIVIDER (7KW)
8 0C8101A 1PANEL, MUFFLER BOX SIDE
0C8861 1 PANEL, MUFFLER BOX SIDE (7KW)
9 0C8101B 1 COVER, MUFFLER BOX
0C8862 1 COVER, MUFFLER BOX (7KW)
10 0C8283 1 GASKET, DOOR SEAL
11 0C8284A 1FOAM, BACK ENCLOSURE
12 0C8284B 1 FOAM,
ROOF ENCLOSURE
13 0C8284C 1 FOAM, FRONT ENCLOSURE
14 0C8285 1 BRACKET, BATTERY SUPPORT
15 0C8899A 1PAD, 24"X48" WITH MOUNTING HOLES
16 0D1128 1 PANEL, ENGINE DIVIDER
0D1128A 1PANEL, ENGINE DIVIDER (7KW)
17 0E4244 1 BAFFLE, INTAKE
0D1605A 1BAFFLE, INTAKE (7KW)
18 0D1606 1 HOUSING, FAN
0D5264 1 BAFFLE, EXHAUST (7K
W)
19 0D1839 2 BRACKET, TOP SUPPORT
20 0D1840 2 BRACKET, BOTTOM SUPPORT
21 0D2425 1 DUCT, BASE AIR
22 0D2588 1 GASKET, FRONT DIVIDER
0D2588A 1GASKET, FRONT DIVIDER (7KW)
23 0D2676 1 COVER, FRONT EXHAUST ENCLOSURE
24 0D2677 1 COVER, BACK EXHAUST ENCLOSURE
25 0D2979B 2 CLOTH, HARDWARE 266.7mm x 146mm
0D2979B 3 CLOTH, HARDWARE 266.7mm x 146mm (7KW)
26 0D2979C 1 CLOTH, HARDWARE 543mm x 146mm
27 0D2979D 1 CLOTH, HARDWARE 266.7mm x 387.4mm
0D2979E 1 CLOTH, HAR
DWARE (7KW)
28 0E4245 1 FOAM, FRONT INTAKE BAFFLE
0D3058A 1FOAM, FRONT INTAKE BAFFLE (7KW)
29 0E4245A 1FOAM, TOP INTAKE BAFFLE
30 0E4245B 1 FOAM, BACK INTAKE BAFFLE
0D3058C 1 FOAM, BACK INTAKE BAFFLE (7KW)
31 0D3057D 1 FOAM, BACK ENCL. STRIP
32 0D3059A 1FOAM, EXHAUST SIDE ENCLOSURE END
33 0D3059B 1 FO
AM, EXHAUST SIDE ENCLOSURE FRONT
34 0D3059C 1 FOAM, EXHAUST FAN HOUSING
35 0D7176 24 WASHER, SELF LOCKING
22 WASHER, SELF LOCKING (7KW)
36 0D3059D 1 FOAM, FRONT EXHAUST ENCLOSURE
COVER
37 0D3059E 1 FOAM, BACK EXHAUST ENCLOSURE COVER
38 0C7781 2 DOOR, PAWL
39 0D3037 1 LATCH, QUARTER TURN LOCKIN
G
40 0D2537 1 HINGE, LIFT OFF, TYPE A PIN
41 0D2538 1 HINGE, LIFT OFF, TYPE B PIN
42 0D3037A 1LATCH, QUARTER TURN NON-LOCKING
ITEM PART NO. QTY. DESCRIPTION
43 0A2115 4 WASHER NYLON .250"
44 022097 9 WASHER LOCK M6-1/4"
45 022473 4 WASHER FLAT ¼" ZINC
46 036261 14 RIVET POP .125 X .129-.133/#30
47 047411 12 SCREW HHC M6-1.0 X 16 G8.8
48 043116 5 SCREW HHC M6-1.0 X 12 G8.8
043116 6 SCREW HHC M6-1.0 X 12 G8.8 (7KW)
49 0D3700 18 NUT, LOCKING FLANGE M6-1.0
50 083512 11 SCREW TAPTITE M8-1.25 X 16 BP
51 090388 36 SCREW TAPTITE M6-1.0 X 12 BP
24 SCREW TAPTITE M6-1.0 X 12 BP (7K
W)
52 092120 2 NUT LOCK TRIC M6 X 1.0 Y/ZNC
54 0D3167 1 GASKET, BATTERY SUPPORT BRACKET
55 0A3328 1 PLUG, PLASTIC 0.593
56 055414 1 LUG SLDLSS #2-#8X17/64 CU
57 092079 1 SCREW TAPTITE M6-1.0X25 BP
58 0A1658 2 L/WASH SPECIAL ¼
59 0C2937 1 BRACKET, BATTERY HOLD DOWN (7KW)
60 086729 1 CONTACTOR, STARTER (7KW)
61 0388040AJ0 1 CABLE, #6 RED BATTERY 38.5"
62 022127 2 NUT HEX 1/4-20 STEEL (7KW)
63 022129 4 WASHE
R LOCK 5/16
022129 5 WASHER LOCK 5/16 (7KW)
64 074908 8 SCREW TAPTITE M5-0.8 X 10 BP
65 0D2346 1 HARNESS, ENGINE
0D2345 1 HARNESS, ENGINE (7KW)
66 023484F 1 BUSHING, SNAP SB-1000-12
67 022142 1 SCREW HHC 5/16-18 X 3/4 G5 (7KW)
68 0A7836 2 RIVET,1/8" X 0.126" - 0.375" LSH POP
69 0A8475 2 L/WASH SPECIAL #10
70 0912970069 1 ASSEMB LY, ROOF / DOOR GROUND WIRE
71 0912970070 2 ASSEMB LY, ROOF / DOOR GR
OUND WIRE
72 055450 2 PLUG PLASTIC 1.375
73 0D2023 10.5 GASKET, CLIP-ON SELF GRIPPING
74 0D3701 1 PLATE, "HOT"
75 0D3472 1 GROMMET 2.75 X 1/16
76 0C8742 1 EXTERNAL CONNECTION BOX
77 0C8911 1 POWER BLOCK
78 0D8442 1 HARNESS GENERATOR TO EXTERNAL
CONNECTION BOX
0D8652 1 HARNESS GENERATOR TO EXTERNAL
CONNECTION BOX (7KW)
79 036937 2 SCREW PPHM #10-32 X 1
80 022152 5 WASHER LOCK #10
81 051713 2 WASHER FLAT M
5
82 022158 5 NUT HEX #10-32 STEEL
83 0D3031 1 FUEL LINE, 3/4"OUTDOOR (NOT SHOWN)
84 026850 1 WASHER SHAKPROOF EXT 1/4 STEEL
85 049813 1 NUT HEX M6-1.0 G8 YELLOW CHROME
86 0D2537A 1HINGE, LIFT OFF, TYPE A KNUCKLE
87 0D2538A 1HINGE, LIFT OFF, TYPE B KNUCKLE
88 047411 2 SCREW HHC M6-1.0 X 16 G8.8
89 0A2311 1 SCREW SWAGE 1/4-20 X 1
90 043107 4 SCREW HHC M8-1.25 X 25
91 022145 8 WASHER FLAT 5/16
92 045771 4 NUT HEX M8-1.25
93 0C3906 2 SELF-
ALIGN SCREW M6 HH
94 0E4321 1 PANEL, EXHAUST ALIGNMENT
Section 8 — Exploded Views and Parts Lists
Centurion 11, 13 and 15 kW Air-cooled Generators
Enclosure – Drawing No. 0D3416-R
To Next Page
Loading...
