74
6. Lightly clean out the dust collects on the
paper element.
7. Replace the air filter as needed.
CAUTION
Do not use liquid cleaner to clean the pa-
per element.
8. Install the air filter. Ensure that the filter is
properly seated on the intake duct.
9. Install the air filter housing cover. Ensure to
securely latch it.
NOTE
Air filter element should be replaced every
50h or 1500 km. Air filter replacement fre-
quency must be increased if the vehicle is
often operated in dusty areas.
Ensure to check if the air filter intake is
clogged. Check if the air filter, throttle body
and intake duct are securely connected.
Fasten all the connections to prevent unfil-
tered air entering the engine.
CAUTION
Do not start the engine without air lter.
Otherwise unltered air will enter the en-
gine and engine premature wear or even
damage may occur. Moreover, driving
without air filter could result in engine
performance degradation and overheat.
Spark Arrester
Cleaning the spark arrester
WARNING
Ensure that the exhaust pipe and muffler
are fully cooled down while servicing the
spark arrester.
To clean the spark arrester, proceed as follows:
1. Remove the retaining screws #1.
2. Remove the spark arrester #2 from the end
of the muffler.
3. Lightly tap the spark plug. Use a metal
brush to clean out the carbon deposits on
To Next Page
Loading...