Challenge Xtreme XSS40A User Manual

14
TROUBLE SHOOTING
PROBLEM POSSIBLE FAULT REMEDY
Engine will not turn
over
Engine stop / start bar
released.
Operate engine stop / start lever.
Incorrect oil level. Check oil level.
Obstruction under deck. Remove obstruction.
Engine smokes Excess oil level. Check oil level.
Air cleaner sponge oil
soaked or blocked.
Service air cleaner.
Engine runs then
stops
Fuel starvation. Fill fuel tank.
Fuel cap vent blocked. Loosen fuel cap then adjust to
finger tight.
Engine will not start Engine under load. Raise height of cut.
Fuel starvation. Fill fuel tank.
Engine cold. Set throttle to ‘choke’ position.
Incorrect/contaminated
fuel.
Drain fuel tank and fill with
correct fuel.
Spark plug lead
disconnected.
Connect spark plug lead.
Faulty spark plug. Clean and adjust gap or
replace.
Engine runs rough Spark plug lead
becoming disconnected
in use.
Connect spark plug lead.
disconnected in use.
Faulty spark plug. Clean and adjust gap or
replace.
Air cleaner blocked. Service air cleaner.
Incorrect/contaminated
fuel.
Drain tank and fill with correct
fuel.
ORIGINAL INSTRUCTIONS
HELPLINE NO 08454505299

Challenge Xtreme XSS40A Specifications

General

Brand	Challenge Xtreme
Model	XSS40A
Category	Lawn Mower
Language	English