EasyManua.ls Logo

Champion 14 DD - User Manual

Champion 14 DD
16 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
110525 9-09
Models
75/85 DD 75/85 SD
95 DD 95 SD
10/12 DD 10/12 SD
14/21 DD 14/21 SD
Circle the model of your cooler and record the
serial number below.
Read Carefully All Of This Manual Before
Installing The Unit.
Encierre con un circulo el modelo de su enfriador y
escribe el número de serie abajo.
Serial #
Número De Serie
Vea el Español en el interior.
Read And Save These Instructions
Safety Instructions ...........................................................................2
Operation ..........................................................................................2
Installation Instructions ................................................................ 2-3
Maintenance Section ........................................................................3
Electrical Wiring Diagrams ..............................................................4
Troubleshooting ...............................................................................5
Warranty ...........................................................................................5
Parts Drawing (Dibujo de Piezas) - 10/12SD, 14/21SD ..................6
Parts Drawing (Dibujo de Piezas) - 10/12DD, 14/21DD ................7
Table Of Contents
Parts List (Lista de Piezas) - 10/12, 14/21 .......................................8
Parts List (Lista de Piezas) - 75/85, 95 ............................................9
Parts Drawing (Dibujo de Piezas) - 75/85DD, 95DD ....................10
Parts Drawing (Dibujo de Piezas) - 75/85SD, 95SD .....................11
Motor Specifi cations (Especifi caciones del Motor) - 75/85DD, 95DD
.10
Motor Specifi cations (Especifi caciones del Motor) - 75/85SD, 95SD
..11
Motor Specifi cations (Especifi caciones del Motor) - 10/12, 14/21
....12
General Specifi cations (Especifi caciones Generales) ...................12
Spanish (Instrucciones en Español) .........................................13-16
Industrial / Commercial
Evaporative Cooler Manual
Lea Con Cuidado Todo Este Manual Antes De
Instalar La Unidad.

Table of Contents

Questions and Answers

  • C
    Courtney AndersonJul 30, 2025
    Why does the motor in my Champion Air Conditioner cycle on and off?
    • V
      Valerie MccoyJul 30, 2025
      If the motor in your Champion Air Conditioner cycles on and off, several issues could be the cause. Start by checking the voltage, as low voltage could be the problem. Also, excessive belt tension might be the reason, so adjust the belt tension. A tight or locked blower shaft could also cause this, so oil or replace the bearings after disconnecting the unit. Dry bearings, a motor pulley diameter that's too large causing motor overload, or a faulty motor could also be the cause. In the case of dry bearings, oil them. If the motor pulley diameter is too large, adjust the pulley so the motor's full load ampere rating isn't exceeded. If the motor is faulty, replace it.
  • G
    Glenn AlvarezAug 4, 2025
    What to do if my Champion 14 DD fails to start?
    • R
      ryanandersonAug 4, 2025
      If your Champion Air Conditioner fails to start or deliver air, there could be several reasons. First, check if there's electrical power to the unit. A fuse might be blown, in which case you should replace it, or a circuit breaker might have tripped, so reset it. Also, the belt might be too loose or tight, so adjust the belt tension. Finally, the motor could be locked, requiring a motor replacement.
  • M
    Mrs. Wendy HernandezAug 11, 2025
    Why is my Champion Air Conditioner not cooling enough?
    • C
      Colleen CastilloAug 11, 2025
      If your Champion Air Conditioner isn't cooling adequately, several factors could be at play. First, make sure there's adequate exhaust in the house by opening windows or doors to increase airflow. Second, check the water distribution system to ensure the pads are adequately wet. Third, the pads might be plugged and need cleaning. Finally, the pump might not be working properly, so consider replacing or cleaning it after unplugging the unit.
  • C
    christopher48Aug 17, 2025
    How to fix a noisy Champion 14 DD Air Conditioner?
    • A
      Ashley SmithAug 17, 2025
      If your Champion Air Conditioner is noisy, here are a few things to check: 1. The bearings might be dry, so oil them. 2. The wheel might be rubbing against the blower housing; in this case, inspect and realign it after disconnecting the unit. 3. There may be loose parts; tighten any loose parts you find.
  • D
    David HammondAug 23, 2025
    What to do if my Champion Air Conditioner smells musty?
    • G
      ggibsonAug 25, 2025
      If your Champion Air Conditioner emits a musty or unpleasant odor, it could be due to stale or stagnant water in the cooler, so drain the pan and clean it. Another cause could be the pads not wetting properly, so check the water distribution.

Summary

Safety Rules

General Operational Safety

Follow all instructions carefully and ensure pump stability during operation.

Electrical Safety Precautions

Disconnect power before work, ensure qualified electrician hookup, and proper grounding.

Power Connection Standards

Connect cooler to proper line current, voltage, and cycle as specified on motor plates.

Motor Installation

Electrical Installation

Water Connection

Maintenance Procedures

Spring Start-Up Tasks

Check belt tension, oil bearings, change pads, clean pump, and inspect bleed-off valve.

Winter Shut Down Tasks

Drain water, disconnect power, and cover the unit to protect it during non-use periods.

Typical Electrical Wiring Diagrams

Electrical Installation Notes

Important notes regarding electrical hookup, supply, and control contacts conformance to codes.

Troubleshooting Guide

Limited Warranty Information

Details warranty coverage, terms, exclusions, and how to obtain service.

Replacement Parts - 10;12 SD & 14;21 SD

Replacement Parts - 10;12 DD & 14;21 DD

Comprehensive Replacement Parts List

Larger Model Replacement Parts List

Champion 14 DD Specifications

General IconGeneral
BrandChampion
Model14 DD
CategoryAir Conditioner
LanguageEnglish

Related product manuals