What to do if there are grease fire or excessive flames on my Char-Broil 463670619 Burner?
If you experience a grease fire or continuous excessive flames above the cooking surface of your Char-Broil Burner, turn off the control knobs and the LP cylinder valve. Leave the lid open to allow the flames to die down. Once the unit is cool, clean any food particles and excess grease from inside the firebox area, grease tray, and other surfaces.
Why is there a sudden drop in gas flow on my Char-Broil 463670619 Burner?
A sudden drop in gas flow or low flame in your Char-Broil Burner, especially if converted to LP (propane), can be due to several reasons: You might be out of gas, the excess flow valve might have tripped, or there could be a vapor lock at the coupling nut/LP cylinder connection. First, check the gas level in your LP cylinder. If gas is available, try turning off the knobs, waiting 30 seconds, and then relighting the grill. If the flames remain low, turn off the knobs and LP cylinder valve, disconnect the regulator, reconnect it, perform a leak test, turn on the LP cylinder valve, wait 30 seconds, and then relight the grill. If it doesn't help, turn off knobs and LP cylinder valve. Disconnect coupling nut from cylinder. Reconnect and retry.
How to repair a gas leak from a damaged Char-Broil 463670619 Burner hose?
If you notice gas leaking from a cracked, cut, or burned hose on your Char-Broil Burner, immediately turn off the gas supply at the source, either on the natural gas system or at the LP cylinder. Stop using the product and replace the valve/hose/regulator. After replacing these parts, conduct a thorough leak check following the instructions in Leak Checking Your Grill.
What to do when Char-Broil 463670619 flames keep blowing out?
If the flames on your Char-Broil Burner keep blowing out, it could be due to high or gusting winds, low LP gas, or a tripped excess flow valve. Try turning the front of the grill to face the wind or increase the flame height by adjusting the gas valve to a higher position. If that doesn't work, refill the LP cylinder. Also, refer to the 'Sudden drop in gas flow' section for guidance.
Why is fire coming through the control panel of my Char-Broil 463670619 Burner?
If you see fire coming through the control panel of your Char-Broil Burner, it's likely due to a fire in the burner tube section caused by a blockage. Immediately turn off the control knobs and the LP cylinder valve. Leave the lid open to allow the flames to die down. Once the fire is out and the grill is cold, remove the burner and inspect it for spider nests or rust. Refer to the Natural Hazard and Cleaning the Burner Assembly pages for additional information.
What causes flashback in Char-Broil Burner tubes?
Flashback, or fire in the burner tubes of your Char-Broil Burner, is typically caused by blocked burner(s) and/or burner tubes. To resolve this, turn the control knobs to the OFF position and clean the burner and/or burner tubes. Refer to the burner cleaning Care and Maintenance Section of this guide for detailed instructions.
What should I do if my Char-Broil 463670619 LP cylinder is leaking gas?
If your Char-Broil Burner, converted to LP (propane), has a gas leak from the LP cylinder, it's likely due to mechanical failure from rusting or mishandling. The solution is to replace the LP cylinder.
How do I fix a Char-Broil 463670619 Burner that won't light with a match?
If your Char-Broil Burner won't light with a match, first check the 'GAS ISSUES:' section. Use a long-stem match (fireplace match) to light it. Also, see the 'Match-Lighting' section of Lighting Your Grill.
What to do if gas is leaking from the LP cylinder valve of my Char-Broil 463670619?
If gas is leaking from the LP cylinder valve of your Char-Broil Burner (converted to LP propane), this is likely due to a failure of the cylinder valve from mishandling or mechanical failure. Turn off the LP cylinder valve and return the LP cylinder to your gas supplier.
Why is gas leaking between the LP cylinder and regulator on my Char-Broil 463670619?
If gas is leaking between the LP cylinder and the regulator connection on your Char-Broil Burner (converted to LP propane), it could be due to improper installation, a loose connection, or a failure of the rubber seal in the cylinder valve. Turn off the LP cylinder valve. Remove the regulator from the cylinder and visually inspect the rubber seal in the cylinder valve for damage. If you see damage or cannot correct the leak, replace the cylinder. For more detailed instructions, see LP Cylinder Leak Test and Connecting Regulator to the LP Cylinder.
Explains safety alert symbols like DANGER, WARNING, and CAUTION.
Procedures for gas leaks, including shutting off gas and evacuating the area.
Warnings about storing flammable liquids near the appliance to prevent fire.
General safety warnings for installation, including LP cylinder hazards and gas leak prevention.
Installation guidelines, local code compliance, and electrical grounding requirements.
Planning the location, airflow, and enclosure construction for optimal side burner performance.
Requirements for LP gas conversion and using non-combustible enclosure materials.
Installing the electronic control module and connecting the natural gas supply line and shut-off valves.
Information on natural gas regulators, pressure testing, and safety warnings.
Instructions for installing the gas supply pipe and external shut-off valves.
Procedures to follow before and after installing the side burner into its enclosure.
Step-by-step instructions for performing a leak test on gas connections using soap and water.
Safe operation practices, emergency actions for gas smells, and proper shutdown procedures.
Essential checks before use, including valve, ignitor, flame, and fuel gas hose condition.
How to light the side burner using the electronic ignitor system.
Instructions for safely lighting the side burner using a match.
Safety tips during use, proper storage, and general cleaning guidelines for surfaces.
Instructions for cleaning plastic, painted, and stainless steel surfaces of the side burner.
Detailed steps for cleaning the burner, venturi tube, and ports to ensure proper performance.
Instructions for securing the side burner into the enclosure using the provided L-brackets.
Actions to take for gas leaks or fires, including calling emergency services.
Troubleshooting common problems with gas flow and electrical ignition systems.
Diagnosing issues with electronic ignition, including no spark, weak spark, or noise.
Addressing common flame issues like blowouts, low flames, and flashback in burner tubes.
Details the scope of coverage, period, and specific exclusions for the product warranty.
Lists specific costs or damages that the manufacturer will not cover under the warranty terms.
Legal disclaimers and limitations on implied warranties and available remedies.
Instructions for registering the product conveniently online via the Char-Broil website.
Step-by-step guide for registering the product by mail using the provided warranty card.
General| Brand | Char-Broil |
|---|---|
| Model | 463670619 |
| Category | Burner |
| Language | English |
To Next Page