Comfort Flame Barkley Series User Manual

Installation and Operation Instructions
Comfort Flame™ Vent Free Barkley Series
Universal Firebox System
Models
BarkleySTXWS
BarkleySTYWS
P/N 900564-00 Rev. N/C 09/2015
PFS
®
US
WELCOME HOME TO WARMTH
TM
P900564-00
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
WARNING: Carefully review the instructions supplied with the decorative type unvented room heater for
the minimum fireplace size requirement.
Do not install the appliance in this firebox, unless this firebox meets the minimum dimensions required for
the installation.
This appliance may be installed in an aftermarket permanently located, manufactured (mobile) home,
where not prohibited by local codes. This appliance is only for use with the type of gas indicated on the
rating plate. This appliance is not convertible for use with other gases.
WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury or
property damage. Refer to this manual for correct installation and operational procedures. For assistance or
additional information consult a qualified installer, service agency or the gas supplier.
WARNING: For use only with a listed, gas-fired unvented decorative room heater not to exceed 40,000
Btu/H.
Do not build a wood fire.
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could result in serious injury, death, or property damage.
— Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other
appliance.
— WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.
• If you cannot reach your gas supplier, call the re department.
— Installation and service must be performed by a qualified installer, service agency or the gas supplier.
Report No. F09-130

Comfort Flame Barkley Series Specifications

General

Brand	Comfort Flame
Model	Barkley Series
Category	Indoor Fireplace
Language	English

Summary

General Safety Information

Firebox Safety Warnings

Key safety precautions and warnings for operation and installation.

Carbon Monoxide Hazard

Crucial warning about the dangers and potential fatality of carbon monoxide poisoning.

Regulatory Compliance

Massachusetts Requirements

Specific installation and safety requirements for the Commonwealth of Massachusetts.

Local Codes and Standards

Adherence to local building codes and National Fuel Gas Code standards.

Product Features and Unpacking

Unpacking Instructions

Steps for safely removing the firebox from its packaging.

Product Components

Description of the firebox's design, blower accessory, and brick liner.

Product Specifications and Location

Firebox Dimensions

Detailed dimensional specifications for the dual-sided firebox.

Locating the Firebox

Guidance on selecting an optimal and safe location for firebox installation.

Air for Combustion and Ventilation

Ventilation Requirements

Explanation of the need for adequate fresh air for combustion and appliance operation.

Determining Airflow

Worksheet and steps to determine required fresh air for confined/unconfined spaces.

Ventilation Airflow Methods

Ventilation Air from Inside

Methods for providing ventilation air from adjoining unconfined spaces.

Ventilation Air from Outdoors

Methods for providing ventilation air directly from outdoors using grills or ducts.

Installation Procedures

Installation Warnings

Critical warnings and cautions regarding safe installation practices and material interactions.

Clearance Requirements

Mandatory clearances from combustibles for safe installation, including wall and ceiling.

Built-In Firebox Installation

Framing and Clearances

Instructions for framing the opening and specific clearance requirements for mantels.

Firebox Mounting

Steps for positioning and securing the firebox into the framed opening.

Gas Line Installation

Framing and Firebox Attachment

Instructions for framing the opening and attaching the firebox securely to wall studs.

Gas Line Connections

Procedure for installing the gas line, including knockout removal and connection points.

Gas Supply Testing and Connections

Gas Line Routing

Guidelines for routing the incoming gas line from either side of the firebox.

Leak Testing Procedures

Critical steps for testing all gas connections for leaks after installation is completed.

Electrical and Blower Installation

Hard-Wiring and Electrical

Instructions for hard-wiring the firebox and connecting the electrical supply for the blower.

Blower Assembly Installation

Step-by-step guide for installing the optional variable speed blower accessory.

Heat Deflective Hoods

Hood Installation Steps

Procedure for installing the essential heat deflective hoods for safe operation.

Operating and Maintenance

Initial Operation and Cleaning

Information on initial log curing odor and recommended cleaning frequency for the appliance.

Operational Safety Warnings

Crucial warnings regarding hot surfaces, child supervision, and servicing safety.

Service, Parts, and Accessories

Service Hints and Technical Support

Common service hints for issues and information for technical assistance.

Replacement Parts Ordering

Instructions for identifying and ordering necessary replacement parts from the manufacturer.

Available Accessories

Information on optional accessories, such as the manual-controlled blower kit.

Parts Identification

Firebox Component Diagram

Exploded view diagram illustrating the various parts of the firebox assembly.

Detailed Parts List

Replaceable Parts Catalog

Comprehensive list of replaceable parts with catalog numbers and model applicability.

Warranty Policy

Limited Warranty Terms and Exclusions

Details of the 20-year limited warranty, including coverage, exclusions, and limitations.

Warranty Claim Process

Procedure for registering the product and making a warranty claim.