Cub Cadet GT 3204 User Manual

IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLY
Warning
: This unit is equipped with an internal combustion engine and should not be used on or
near any unimproved forest-covered, brush-covered or grass-covered land unless the engine’s
exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a
spark arrester is used, it should be maintained in effective working order by the operator. In the State
of California the above is required by law (Section 4442 of the California Public Resources Code).
Other states may have similar laws. Federal laws apply on federal lands. A spark arrester for the
muffler is available through your nearest engine authorized service dealer or contact the service
department, P.O. Box 361131 Cleveland, Ohio 44136-0019.
CUB CADET LLC P.O. BOX 361131 CLEVELAND, OHIO 44136-0019 [www.cubcadet.com]
FORM NO. 770-10516B
(10/03)
OPERATOR’S MANUAL
TRACTOR
Model GT 3204
SERIES 3000

Cub Cadet GT 3204 Specifications

General

Type	Garden Tractor
Engine Cooling	Air
Fuel	Gasoline
Cylinders	2
Transmission	Hydrostatic
Drive	2WD
Steering	Power Steering
Front tire size	16 x 6.5-8
Rear tire size	23 x 10.5-12
Cutting width	54 inches
Blades	3
Turning Radius	18 inches
Deck Material	Steel
Engine	Kohler Command
Engine Series	Command
Brakes	Disc
Cutting Height	1-4 inches
Warranty	2 years

Summary

Tractor Preparation

Connect the Battery

Important Safe Operation Practices

General Operation

Guidelines for safe general operation of the tractor.

Slope Operation

Safe practices and warnings for operating the tractor on slopes.

Children Safety

Safety precautions regarding children and tractor operation.

Service Safety Precautions

Safety Labels Found on Your Unit

Controls Overview

Oil Pressure Indicator

Low Fuel Indicator

Operation Procedures

Safety Interlock Switches

Explanation of the tractor's safety interlock system and its functions.

Fueling The Tractor

Guidelines for safely fueling the tractor with approved gasoline.

Starting The Engine

Step-by-step procedure for starting the tractor engine.

Driving The Tractor

Instructions and warnings for driving the tractor safely.

Driving On Slopes

Critical safety advice and procedures for operating on slopes.

Using The Hydraulic Lift System

Engaging The PTO

Procedure for engaging the Power Take-Off (PTO) clutch.

Mowing

Best practices and warnings for mowing with the tractor.

Adjustments

Front Wheel Alignment

Adjusting the Brake

Maintenance Schedule

Maintenance Chart

Schedule for routine maintenance operations based on usage hours.

Engine Compartment and Battery

General Battery Information

Charging the Battery

Checking Transmission Oil Level

Transmission Oil Procedures

Adding Transmission Oil

Changing Transmission Oil

Steps for draining and replacing the transmission oil.

Electrical System and Storage

Oil Filter Replacement

Fuse Check and Replacement

Off-Season Storage Procedures

Recommended procedures for storing the tractor during the off-season.

Engine Information and Warranty

Manufacturer's Warranty Coverage

Details on the engine's warranty coverage for defects.

Owner's Warranty Responsibilities

Warranty Limitations

Maintenance and Repairs Requirements

Engine Care

Cleaning The Engine

Checking Engine Oil Level

Procedure for checking the engine oil level before operation.

Adding Engine Oil

Correct method for adding engine oil to the crankcase.

Changing Engine Oil

Steps for safely draining and replacing engine oil and filter.

Sparkplug Maintenance

Changing Fuel Filter

Changing Air Cleaner

Trouble Shooting

Hard To Start

Common causes and remedies for engine starting issues.

Engine Operates Irregularly or Knocks

Troubleshooting guide for irregular engine operation or knocking.

PTO Clutch Will Not Engage

Reasons why the PTO clutch may not engage and how to fix them.

Lack of Power

Causes of reduced tractor power and their solutions.

Fuel System Issues

Slope Gauge

Manufacturer's One Year Limited Warranty (Commercial Use)

How to Obtain Service (Commercial Use)

Manufacturer's Limited Warranty (Residential Use)

5 Year/500 Hour Limited Warranty

How to Obtain Service (Residential Use)