Heavy Duty Power Equipment Troubleshooting
SECTION 6: TROUBLESHOOTING
Problem Cause Remedy
Engine fails to start
Engine runs erratic
Too much vibration
Engine overheats
1. Spark plug wire disconnected.
2. Fuel tank empty or stale fuel.
3. Throttle control lever not in correct starting
position. (If Equipped)
4. Choke not in CHOKE position. (If equipped)
5. Engine not primed.
6. Blocked fuel line.
7. Faulty spark plug.
1. Spark plug wire loose.
2. Unit running on CHOKE. (If equipped)
3. Blocked fuel line or stale fuel.
4. Water or dirt in fuel system.
5. Dirty air cleaner.
6. Carburetor out of adjustment.
1. Loose parts or damaged impeller.
1. Engine oil level tow.
2. Dirty air cleaner.
3. Carburetor not adjusted properly.
1. Connect wire to spark plug.
2. Fill tank with clean, fresh gasoline.
3. Move throttle lever to FAST position.
4. Move choke to CHOKE position.
5. Prime engine.
6. Clean fuel line.
7. Clean, adjust gap, or replace.
1. Connect and tighten spark plug wire.
2. Move choke lever to OFF position.
3. Clean fuel line; fill tank with clean, fresh gaso-
line.
4. Drain fuel tank. Refill with fresh fuel.
5. Clean or replace air cleaner.
6. See authorized service dealer.
1. See authorized service dealer.
1. Fill crankcase with proper oil.
2. Clean or replace air cleaner.
3. See authorized service dealer.
Occasional skip (hesitates) 1. Spark plug gap too close. 1. Adjust gap to.030".
Unit does not discharge 1. Discharge chute clogged. 1.
Rate of discharge slows
2. Foreign object lodged in impeller.
3. Low engine RPM.
1. Low engine RPM.
2. Chipper blade dull.
2,
3.
Stop engine immediately and disconnect
spark plug wire. Clean flail screen and inside
of discharge opening.
Stop engine and disconnect spark plug wire.
Remove lodged object.
Always run engine at full throttle.
1. Always run engine at full throttle
2. Replace chipper blade or see your authorized
service dealer.
NOTE: For repairs beyond the minor adjustments listed above, contact your nearest authorized service dealer.
Rev: April 2011
DEK® is exclusively distributed by GXi Outdoor Power LLC
11 of 12
To Next Page
Loading...