F.
0
Check LP gas safety shut-off. See Section A.
Installation, /tern 9, Testing LP Gas Shut-OFF.
U. The Electrode
11. Allow 10 minutes for the LP gas to leave
the burner area. Reconnect the 12 volt DC
power. Light the burner per Section B.
Operating Instructions, Item 3, Gas Opera-
tion. Allow burner to run 5 minutes.
12. Connect power cord to the 120volt AC wall
outlet.
For a proper ignition function it is necessary to
keep the electrode insulation dry and free from
dirt. The gap between burner tube and electrode
shall be a maximum of 3/16” (5mm) and a
minimum of l/8” (3mm). (See Fig. 16).
Fig. 16
NOTE:
Avoid spraying water through the
refrigerator’s vents while washing your RV.
2. Troubleshooting
n
THE REFRIGERATOR DOES NOT COOL
PROPERLY
Causes and Remedies:
A. Burner jet clogged. Remove the burner jet. Soak
the jet in wood alcohol and blow it out with com-
pressed air. Do not use a wire or pin to clean the
burner jet.
B.
C.
D.
E.
F.
G.
Refrigerator is not level.
Flame has gone out.
Remedy: 1) Gas bottle is empty
-
refill. 2) The tip
of the flame failure safety device is not heated
enough by flame. 3) Clogged bypass screw
-
clean or exchange it.
Venting problem.
Restriction in air flow across cooling unit.
Heavy frost build-up on evaporator fins.
Defrost.
Flue baffle not inserted properly in flue tube.
Improperly set thermostat.
See paragraph on thermostat. In hot weather the
setting should be closer to “MAX” than usual.
H.
I.
J.
Burner dirty.
Clean.
Burner damaged.
Replace.
LP gas pressure low at burner.
Set main regulator so the pressure does not drop
below 11 inches water column at pressure tap.
K. Burner not located properly under flue tube.
Relocate.
n
ODOR FROM FUMES
Causes and Remedies:
A. The flame touches side of boiler due to dislocation
of burner. Relocate. Burner dislocation may also
cause smoke and discoloring of walls and ceiling.
B. Burner damaged. Replace.
C. The flue tube is dirty. Clean flue as
follows:
Cover
burner and burner jet. Remove the flue cap from
the top of the flue tube and lift out the wire and
spiral baffle. Clean the flue from the top using a
flue brush. Clean the spiral baffle. Replace the
spiral baffle and flue cap.
All the instructions are to be followed closely. The
refrigerator is quality-guaranteed. However, we are not
responsible for any failures caused by improper
adjustments and unfavorable installation conditions.
To Previous Page
Loading...
