Eclipse Algas-SDI POWER Series - P-Series Electric Vaporizer Data Sheet

P-Series Electric Vaporizer Data Sheet
Additional Drawings:
Rev.
Rev.
Refer to Nameplate on unit for the model and voltage information then look up specific information on
the tables below.
General Specifications:
Applies to all units, see Capacity Table below for specific information.
Electrical:
3 Phase, 3 Wire, 50-60 Hz
Electrical Enclosure Rating:
Nema 4
Starting Temperature:
Operating Temperature:
1st High Temperature Limit:
2nd High Temperature Limit:
Connections P120 / P160:
Conduit:
1-1/4" Conduit Seal-Off on Division 1 units by others
Type of Service:
Propane Vaporization
ASME Pressure Vessel:
Wiring:
Meets NFPA Pamphlet 70 requirements for Class 1 Division 1 Group D or Class 1 Division 2 Group D
Other:
Meets NFPA Pamphlet 58 requirements for electric vaporizers and may be installed per indirect fired
vaporizer limitations.
Table: Single Vaporizer
Ca
p
acities based on 0
O
F
(
-17.8
O
C
)
@
100
p
si
g
(
7.0 k
g
G/cm
2
)
Shipping weight is an approximation
7.1ft
2
/0.66m
2
225 / 102
70
90 - 95
176
Deg. C
Deg. C
Deg. C
158 Deg. F
157 301 3.6314.4
P160
575 39.4 39.2
225 / 102
194 - 203 Deg. F
349 Deg. F
1" NPT Outlet
7.1ft
2
/0.66m
2
7.1ft
2
/0.66m
2
225 / 102
P160
480 47.4 39.4 157 302 3.6414.4
3/4" NPT Inlet
250 PSIG MAWP
157 302
26.8 107 205
KG/HRGPH
3.6414.4
P160
440 51.7 39.4
225 / 102
P160
415 54.8 39.3 157 302 3.6414.4
7.1ft
2
/0.66m
2
7.1ft
2
/0.66m
2
225 / 102
157 301 3.6314.4
P160
380 59.7 39.3
225 / 102
P160
240 94.9 39.4 157 302 3.6414.4
7.1ft
2
/0.66m
2
7.1ft
2
/0.66m
2
225 / 102
157 302 3.6414.4
P160
220 103.5 39.4
225 / 102
P160
208 97.8 35.2 141 270 3.2512.9
7.1ft
2
/0.66m
2
5.5ft
2
/0.51m
2
180 / 81.9
119 229 2.7610.9
P120
575 30 29.8
180 / 81.9
P120
480 42.9 35.6 142 273 3.2913.1
5.5ft
2
/0.51m
2
5.5ft
2
/0.51m
2
180 / 81.9
120 230 2.7711.0
P120
440 39.3 29.9
180 / 81.9
P120
415 49.6 35.6 142 273 3.2913.0
180 / 81.9
119 229 2.7610.9
P120
380 45.4 29.8
180 / 81.9
P120
240 85.8 35.6 142 273 3.2913.1
180 / 81.9
120 230 2.7711.0
P120
220 78.6 29.9
MODEL
P120
208 74.3
CURRENT
AMPS
VOLTAGE
VAC
180 / 81.9
WEIGHT
LBS / KG
HEAT
EXCHANGE
AREA
Million
BTU/HR
9.8 5.5ft
2
/0.51m
2
2.47
POWER
KW
5.5ft
2
/0.51m
2
5.5ft
2
/0.51m
2
5.5ft
2
/0.51m
2
5.5ft
2
/0.51m
2
Million
KCAL/HR
160 Deg. C 320 Deg. F
"POWER is a trademark of Algas-SDI, Patent Number 4645904