England's Stove Works 24-JC User Manual

INSTALLATION AND OPERATION MANUAL
Thank you for purchasing this product from a fine line of heating equipment.
We wish you many years of safe heating pleasure.
Visit our web page at
www.englandsstoveworks.com for helpful information,
frequently asked questions, parts & accessory orders and more.
NOTE: IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT TO
THE DEALER. CONTACT CUSTOMER SERVICE @ 1-800-245-6489.
CAUTIONS AND WARNINGS:
READ THESE INSTRUCTIONS CAREFULLY BEFORE INSTALLATION
CAUTION: This unit must be installed in accordance with these instructions and must
comply with local building and fire codes. Failure to do so could result in a chimney or
house fire, property damage, bodily injury or even death.. Keep children, furniture,
fixtures and all combustibles away from any heating appliance.
England’s Stove Works highly recommends the use of smoke detectors and Carbon
Monoxide detectors with any hearth product, including this unit. Follow all manufacturer’s
instructions when using smoke or Carbon Monoxide detectors.
DO NOT INSTALL THIS UNIT IN A MOBILE HOME OR DOUBLE WIDE!
DO NOT INSTALL THIS UNIT IN A PRE-MANUFACTURED FIREPLACE!
FOR MASONRY FIREPLACE INSTALLATION ONLY.
This product contains a catalytic combustor, which needs periodic inspection and
replacement for proper operation. It is against the law to operate this wood heater in a
manner inconsistent with the instructions in the manual or if the catalytic element is
deactivated or removed.
Our catalytic stoves are designed to burn seasoned, dry wood.
24-JC, 50-SHW20 and 50-TRW20
COMPLIANCE STATUS
TYPE OF FUEL WOOD
EMISSION RATE 2.1 GRAMS PER HOUR
OVERALL EFFICIENCY 83.04%
HEAT OUTPUT TEST RANGE 7,200 TO 28,600 BTU/HR
EPA CERTIFICATE NUMBER 267
THIS UNIT IS CERTIFIED TO EPA PHASE II STANDARDS
Rev. 1/06

England's Stove Works 24-JC Specifications

General

Fuel Type	Wood
Efficiency	75%
EPA Certified	Yes
Material	Steel
Dimensions	27.5" H x 24.5" W

Summary

Cautions and Warnings

Mobile Home Installation Prohibited

Prohibits installation of this unit in mobile homes or double-wide units.

Pre-Manufactured Fireplace Prohibition

Explicitly forbids installation in pre-manufactured fireplaces; masonry only.

Compliance Status

Section I: Flue System

Flue Size Requirements

Details required flue connector pipe size and chimney liner area relative to stove opening.

Section II: Floor Protection

Hearth Extension Needs

Specifies minimum hearth extension required in front of the fireplace door.

Section III: Installation Into a Masonry Fireplace

A. Preparation

Outlines initial checks and preparation for fireplace installation, including hearth measurement and inspection.

B. Venting Methods

Details two methods: Direct Connect using 8-inch pipe and Direct Dump with a cover plate.

Section V: Operating Instructions

A. Building a Fire Procedure

Step-by-step guide for starting and maintaining a fire, including use of by-pass damper.

B. Draft Control Adjustment

Explains the function of the slide damper for controlling combustion air and heat output.

C. Preventing Over-Firing

Warns against over-firing and outlines actions to take if the unit or chimney pipe overheats.

D. Everyday Fueling and Burn Cycles

Provides guidance on fueling the stove for extended burn times and subsequent re-fueling.

E. Ash Removal and Disposal

Instructions for safely removing and disposing of ashes from the stove.

Section VI: Care and Maintenance

A. Catalytic Combustor Care

Details inspection, cleaning, and replacement procedures for the catalytic combustor.

B. Gasket Replacement

Guidance on replacing door and window gaskets, including adhesive application and curing time.

C. Firebrick Replacement

Advice on checking for and replacing chipped or cracked firebricks within the firebox.

D. Finish Maintenance

Information on the high-temperature paint finish and touch-up procedures for rust spots.

E. Blower System Maintenance

Instructions for cleaning the blower system annually to ensure optimal performance.

F. Glass Cleaning Procedures

Methods for cleaning the viewing glass, noting the effect of wood type and operation mode.

Section VII: Chimney Maintenance

Section VIII: Things That Cause the Unit to Smoke

Section IX: What Causes Creosote?

Limited 5 Year Warranty

Five Year Warranty Coverage

Covers carbon steel, welded seams, cast iron door, hasp, and hinges for 5 years against splitting/cracking.

One Year Warranty Coverage

Covers component parts like housing, flue collar, firebrick, glass, and painted surface for 1 year.

Warranty Conditions and Exclusions

Outlines conditions that void the warranty, such as over-firing, abuse, and improper installation.

Warranty Claim Procedure

Details the process for submitting a warranty claim, including notice and transportation responsibilities.

Other Warranty Rights

Mentions specific legal rights and state-varied rights related to the warranty.