ⅰ.the exterior of the battery ,the connection wires and bolts should be kept clean and dry .If there is electrolyte outside the battery, please clean with dry
cotton yarn firstly,then wash with water and finally wipe up .(while cleaning ,do not allow any cleaning solution ,or water to get inside the battery, to avoid
leakage and increasing self-discharge)
ⅱ. The connection of the battery should always be kept in good condition .please check if any battery cable terminal or nut has become loose periodically in
order to prevent any sparkle or damage to terminals .
ⅲ.Do not place any object on the battery and do not connect the positive pole to the negative pole .this may cause a short circuit ,damage to the battery or
injury to your body .
ⅳ.The battery should be recharged fully when not in use . any delay on the re-charging will cause negative effect on the battery .
ⅴThe evaporation and electrolyzing of the water will cause the density of electrolyte of the battery increased and the liquid surface decrease ,especially in
hot water.therefore,check the distilled water or the attenuated sulfuric acid for lead-acid battery with density of 1.40 to adjust the electrolyte to meet the
density of the 1.28,the surface should be flat with highest level then continue to charge0.5-1 hour in order to make the internal uniform .
ⅵ.Any impurities are not allowed to enter the battery. Keep the apparatus clean for adding water to avoid the impurities to be fallen into the battery.
ⅶ.When driving , the driver shall be always be aware of the drop level the battery power from the batteries’ capacity indicator .the driver shall estimate the
distance needed to be taken,and recharge the battery at a proper time in case that the car can not get back to the recharging station in time for recharging .
ⅷ. If the golf car is going to be kept unused for a period of time ,the battery shall be fully charged before put away. After that ,the battery fully recharged
every month ,until the charger turn off automatically
ⅸ.During charging ,the car shall be parked in a well-ventilated area with the fill caps open. Keep car far away from any frame and sparks and avoid any
explosion or fire that could cause physical injury or damage to the property. ⅹ.once charged the cap should be kept tightly covered.
Charging should be performed when ambient temperatures are between 32°F and 110°F (0°C and 45°C).
The battery pack should be charged or topped off after every use.
Charging steps:
Turn the key to the OFF position and remove it.
Inspect the charger cord for cracks, frayed wires or loose connections, if damaged replace it.
Inspect the vehicle charger receptacle and charger plug for dirt, debris or damage. Clean if necessary
and replace immediately if damage is found.
Connect the charger to a wall receptacle. Do not use a multi-plug adapter or power strip. Do not
connect anything else to the same receptacle.
When the battery pack is finished charging, disconnect the charger cord from the vehicle. If
disconnecting before the charge cycle is complete, it is recommended that the charger be
disconnected from the wall receptacle first, then unplug the charger from the vehicle receptacle.
To Next Page
Loading...
Need help?
General
