Ezgo EXPRESS L4 User Manual

Page A-8
Repair and Service Manual
B
GENERAL INFORMATION & ROUTINE MAINTENANCE
Read all of Section B and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
Steering Assembly - excessive play, loose or missing
hardware
* * * *
Tie Rods - excessive play, bent rods, loose or missing
hardware
* * * *
Rear Axle - fluid level, oil leakage, noise, loose or
missing hardware
* * * *
Rear Axle - drain & replace fluid R
Rear Suspension - shock oil leakage, worn bushings,
loose or missing hardware
* * *
Front Suspension - strut oil leakage, excessive play in
hubs or kingpins, worn bushings, loose or missing
hardware
* * * *
Front Wheel Alignment - unusual tire wear C&A C&A C&A
Fuel System - leaks at tank, cap, system lines for
cracks/deterioration, filters, pump
* * *
Fuel Filter R
Spark Plug R
Throttle/Governor Linkage - operation & governed
speed
* * *
Air Filter Element - check & replace as necessary
* *
Drive Belt - cracks, frayed, excessive wear
* *
REMARKS
before each use DAILY WEEKLY
20 rnds/20 hrs 100 miles/160 kms MONTHLY
60 rnds/60 hrs 300 miles/500 kms QUARTERLY 125 rnds/125 hrs 600miles/1000 kms SEMI-ANNUAL 250 rnds/250 hrs 1200miles/2000 kms ANNUAL 5 YEARS PAGE
Fig. 7 PERIODIC SERVICE SCHEDULE
**Initial oil change after 8 hours of run time.
NOTE: Some maintenance items must be serviced more frequently on vehicles used under severe driving conditions.

Ezgo EXPRESS L4 Specifications

General

Brand	Ezgo
Model	EXPRESS L4
Category	Utility Vehicle
Language	English