38
MAINTENANCE
BATTERY CLEANING
Clean the batteries according to the Periodic Service Schedule.
Always wear eye protection when cleaning the battery.
To prevent battery damage, make sure you correctly install all battery caps.
NOTICE: To decrease the risk of damage to vehicle or floor, neutralize acid before you spray the battery with
water. To decrease the risk of damage to electrical components surrounding the battery while clean-
ing, do not use a pressure washer.When you clean the battery cases and terminals, do not use a
water hose without neutralizing any acid deposits first. The water hose moves the acid from the top
of the batteries to another area of the vehicle or storage facility, where it can cause damage. After
spraying the batteries, a conductive residue remains on the batteries and contribute to the dis-
charge of the batteries.
Remove corrosion with a wire brush.
6. Wash top and sides of the batteries with a solution of:
• 2 tsp. (10 ml) baking soda
• 1 quart (1 liter) water
Wash all metal components near the battery.
7. Allow the solution to set a minimum of three minutes. Use a soft bristle brush or cloth to clean the top of each bat-
tery to remove residue that can cause the discharge of the battery.
8. Rinse with tap water and dry with shop towels.
9. After the batteries are clean and dry, coat the terminals with a commercially available battery terminal spray.
BATTERY CHARGING AND MAINTENANCE
Hydrogen gas is produced as batteries are charged. Charge batteries only in well-venti-
lated areas.
At Each Charging Cycle
• Before you charge the batteries, inspect the plug of the battery charger and vehicle receptacle housing for dirt
or other particles.
• Charge the batteries after each use.
Monthly
• Inspect all wires for wear, loose connections, corrosion or damage of insulation.
• Make sure that the electrolyte level is correct and add clean water as required.
• Clean the batteries and wire connections.
• Apply battery protectorate to the battery terminals.
Tools
• insulated wrench, 9/16” • battery carrier
• hydrometer • battery maintenance kit (P/N 25587-G01)
• battery protective spray
To Next Page
