Ferno NeoMate 679 - Maintenance and Care; Maintenance Schedule; Disinfecting and Cleaning Procedures; Inspection Checklist

Model Neomate
5  MAINTENANCE
Maintenance Schedule
The Neomate requires regular maintenance. Set up and
follow a maintenance schedule (see maintenance record
sheet on page 14). The table at right represents minimum
intervals for maintenance.
When using maintenance products, follow the manufacturers'
directions and read the manufacturers' material safety data
sheets.
Disinfecting the Neomate
Wipe or spray disinfectant on all Neomate and surfaces
and straps. Follow the disinfectant manufacturer's directions
for application and contact time.
Cleaning the Neomate
Hand wash the Neomate blanket and straps with warm,
soapy water and a clean cloth or soft brush. Rinse with clear
water. Dry the blanket with a towel and allow the straps to
air dry.
Do not immerse the buckles in water.
Inspecting the Neomate
Have your services equipment maintenance personnel
inspect the Neomate regularly. Follow the inspection
checklist.
If the inspection shows damage or excessive wear, remove
the Neomate from service. Ferno recommends that in
addition to scheduled maintenance, operators perform
a visual inspection each time the Neomate is used. If
damage is noted, remove the Neomate from service
immediately and replace it.
INSPECTION CHECKLIST
● Are all components present?
● Is the Neomate free of excessive wear?
● Is all stitching secure?
● Do the central buckle and adjustment tabs operate
properly and smoothly?
● Are there cuts or tears in the blanket or straps?
WARNING
Improper maintenance can cause injury. Maintain
the Neomate only as described in this manual.
Important
Disinfectants and cleaners containing bleach,
phenolics, or iodines can damage the Neomate. Do
not use products containing these chemicals.
Important
If the Neomate is in use at the time of a vehicular
accident, remove the Neomate from service and
replace it.
Maintenance
U.S.A. NOTICE
The cot is for use with ambulances that meet the requirements
of the “Star of Life” certication via FederalAmbulance
SpecicationKKK-A-1822.Forinformation,contact:
FederalSupplyServices,SpecicationsSection
Suite 8100
470 E. L’Enfant Plaza, SW
Washington, DC 204
Minimum
Maintenance Intervals
Each Use As Needed Each Month
Disinfecting (this page)
•
Cleaning (this page)
•
Inspecting (this page)
••