This document describes the Jackson Round Aluminum LPG Fire Pit from Fire Sense, a product designed for outdoor decorative gas appliance use.
Function Description
The Jackson Round Aluminum LPG Fire Pit is a combustion appliance that provides heat and ambiance for outdoor spaces. It operates on Liquid Propane (LPG) gas, delivered via a standard 20lb propane cylinder (sold separately). The fire pit features an electronic igniter for easy startup, which requires one AAA battery (not included). It is also convertible to Natural Gas (NG) with additional parts (NG regulator and hose, not included) and a conversion kit. The appliance is designed to produce a minute, non-hazardous amount of carbon monoxide when used and maintained according to instructions.
Important Technical Specifications
- Model: Jackson Round Aluminum LPG Fire Pit
- Ignition: Electronic Igniter (requires 1 AAA battery)
- Fuel Type: Liquid Propane (LPG), convertible to Natural Gas (NG)
- LPG Cylinder: Standard 20lb propane cylinder (sold separately), vapor withdrawal supply system.
- Maximum LPG Inlet Gas Supply Pressure: 250 PSI
- Minimum LPG Inlet Gas Supply Pressure: 5 PSI
- Minimum Hourly Input Rating (for automatic operation): 10,000 BTU
- LPG Input Rate (Pressure 11"): 55,000 BTU/h (Orifice Size: 2.3mm)
- NG Input Rate (Pressure 7"): 55,000 BTU/h (Orifice Size: 3.78mm)
- Construction Material: Aluminum
- Clearances from Combustible Materials:
- Sides: 2 feet (24 inches)
- Rear: 2 feet (24 inches)
- Top (Ceiling): 6 feet (72 inches)
- Cross-Ventilation Requirement: Minimum 18 inches in all directions.
- Certifications: ANSI Z21.97-2017, CSA STD 2.41-2017 Outdoor decorative gas appliances.
Usage Features
The fire pit is designed for outdoor use only and should never be used indoors or in any enclosed, unventilated areas due to the risk of carbon monoxide poisoning.
Assembly:
- Requires two people for assembly.
- Estimated assembly time: 60 minutes.
- Hardware is included, with extra pieces provided for common components like studs, washers, and nuts.
- The igniter button needs to be unscrewed to install a AAA battery (positive end facing out).
- Fire glass is poured around the burner, taking care not to obstruct the pilot light housing.
- A removable burner cover is included.
- The propane cylinder connects to the fire pit via a hose and regulator assembly (supplied with the appliance).
Operation:
- Leak Check: Mandatory before first use and whenever gas connections are loosened or removed. Performed outdoors with a soap and water solution.
- Lighting:
- Turn the control knob to "OFF."
- Fully open the LP cylinder valve. For initial start or after a cylinder change, hold the control knob IN for 2 minutes to purge air from gas lines.
- Push in and turn the control knob counterclockwise to "HIGH."
- While holding the control knob in, push the Electronic Ignition button to ignite the main burner.
- After the fire pit lights, wait 45 seconds, then release the control knob.
- Flame height should be between 3 and 13 inches.
- To decrease the flame, turn the control knob clockwise to "LOW." To increase, turn counterclockwise to "HIGH."
- Shut Down:
- Depress the control knob and turn it clockwise to "OFF."
- Turn the cylinder valve clockwise to "OFF" and disconnect the regulator when not in use.
- Safety Precautions:
- Keep solid combustibles at least 2 feet from sides/rear and 6 feet from top.
- Never store propane near high heat, open flames, or ignition sources.
- Propane vapors are heavier than air; if gas is smelled, leave the area immediately.
- Do not install or remove a propane cylinder while the fire pit is hot or lit.
- Never leave the fire pit unattended when hot or in use.
- Keep out of reach of children.
- Do not sit, stand, or lean heavily on the fire pit top to prevent bending or warping.
- Do not use in windy conditions (wind velocity below 10mph is recommended).
- The unit will operate at reduced efficiency below 40°F.
Natural Gas Conversion:
- Requires a licensed gas fitter for installation and leak testing.
- Involves replacing the propane orifice with a natural gas orifice (supplied in the conversion kit) and replacing the LPG hose and regulator with an NG regulator and hose (not included).
- A conversion label must be placed inside the tank access door.
- The gas supply line must be purged of trapped air prior to first firing.
Maintenance Features
- Cleaning: Use warm soapy water; avoid flammable or corrosive cleaning agents. Keep the burner and control compartment dry. Ensure the fire pit has cooled completely before cleaning or covering.
- Airflow: Maintain unobstructed airflow. Keep controls, burner, and circulating air passageways clean.
- Blockages: Regularly check for and clear spider/insect nests or other blockages in burner orifices and air circulation passages using a heavy-duty pipe cleaner or compressed air.
- Carbon Deposits: Clean burner screen with warm soapy water if carbon deposits develop.
- Corrosion: In salt-air environments, check for and repair corroded areas promptly.
- Annual Inspection: The fire pit should be inspected by a qualified service person at least annually.
- Storage:
- Between Uses: Turn control knob OFF, disconnect LP source, store in a sheltered area from inclement weather, and cover to protect surfaces and prevent build-up in air passages.
- Extended Inactivity/Transport: Turn control knob OFF, disconnect LP source, move to a secure, well-ventilated outdoor location. Never leave LP cylinder exposed to direct sunlight or excessive heat. Wait until the fire pit is cool before covering.
- Service: Only a qualified service person should repair gas passages and associated components.
- Standard Warranty: 1 year from original purchase date against defects in materials and workmanship under normal use, with proof of purchase from an authorized retailer.
- Exclusions: Normal wear/weathering, exposure to water/freezing temperatures/oils/fluids/chemicals, commercial use (unless designated commercial model), accidents, negligence, misuse, abuse, neglect, mishandling, alteration, modification, failure to maintain, improper assembly/maintenance, service by unauthorized agency, unauthorized components, or acts of God.
- Warranty Extension: An additional year of warranty can be obtained by reviewing the item at balkenehome.com within 365 days of purchase.
- Customer Service: Contact Well Traveled Living (Florida-based) for warranty service or assistance with questions, problems, or missing parts.
- Toll-free: (866) 985-7877 (9 a.m. - 9 p.m., EST)
- Email: cservice@welltraveled.net
- Live chat: www.balkenehome.com (9 a.m. - 6 p.m., EST, Monday - Friday)
Need help?
General
To Next Page