Firegear FPB-19RBS16TPSI-N - User Manual

IF YOU CANNOT READ OR UNDERSTAND THESE INSTALLATION INSTRUCTIONS
DO NOT ATTEMPT TO INSTALL OR OPERATE THIS APPLIANCE
DO NOT DISCARD. THIS MANUAL
HAS IMPORTANT OPERATING AND
MAINTENANCE INSTRUCTIONS.
LEAVE WITH THE HOMEOWNER.
MODEL:
SERIAL #:
Warning: For Outdoor Use Only
Outdoor Thermocouple Piloted
Safety Ignition (TPSI) Fire Pits
Installation and Operating Instructions
Natural Gas Models Description Propane Gas Models
FPB-19RBS16TPSI-N 19” Rd Drop-In Pan with 16” Stainless Spur Burner FPB-19RBS16TPSI-P
FPB-25RBS22TPSI-N 25” Rd Drop-In Pan with 22” Stainless Spur Burner FPB-25RBS22TPSI-P
FPB-29RBS22TPSI-N 29” Rd Drop-In Pan with 22” Stainless Spur Burner FPB-29RBS22TPSI-P
FPB-33RBS31TPSI-N 33” Rd Drop-In Pan with 31” Stainless Spur Burner FPB-33RBS31TPSI-P
FPB-20SBS16TPSI-N 20” Sq Drop-In Pan with 16” Stainless Spur Burner FPB-20SBS16TPSI-P
FPB-26SBS22TPSI-N 26” Sq Drop-In Pan with 22” Stainless Spur Burner FPB-26SBS22TPSI-P
FPB-32SBS31TPSI-N 32” Sq Drop-In Pan with 31” Stainless Spur Burner FPB-32SBS31TPSI-P
MODELS
INSTALLATION PRECAUTION:
This system requires a minimum 18 square inches (per side) of cross ventilation.
Failure to provide proper ventilation will void the warranty.
#20-025
PN#90261
NOTE: All TPSI models come shipped from the factory as Natural gas or Propane (LP)
gas. They must be order specically as Natural gas or Propane models and cannot be
eld converted from one gas to another.

Summary

Outdoor Thermocouple Piloted Safety Ignition (TPSI) Fire Pits

Model Identification

Installation and Operating Guide

Provides comprehensive guidance for installing and operating the TPSI fire pits.

Installation Precautions

Details essential requirements for safe installation, such as ventilation and clearances.

Safety Information and Warnings

Carbon Monoxide Hazard

Explains the risks associated with carbon monoxide production and the dangers of enclosed spaces.

Fire and Explosion Hazards

Details procedures for gas leaks, fire prevention, and safe handling of fuel.

General Operational Warnings

Covers unattended use, adherence to manual, flammable storage, and proper installation safety.

Technical Specifications and Dimensions

Fire Pit Dimensions Table

Btu and Orifice Specifications

Gas Pressure Requirements

Specifies minimum, maximum, and normal inlet gas pressure for NG and LP.

Gas Pipe Sizing Guidance

Natural Gas Pipe Sizing

Provides charts for selecting appropriate pipe sizes based on BTU and length for Natural Gas.

Liquid Propane Pipe Sizing

Provides charts for selecting appropriate pipe sizes based on BTU and length for Propane.

Installation Preparation and Considerations

Non-Combustible Structure Preparation

Gas Piping Installation

Guidance on connecting gas lines and ensuring proper installation for safety and performance.

Component Handling and Initial Setup

Installing the Burner Orifice

Control Panel Mounting

Pilot System and Media Installation

Lava Rock;Media Installation

Detailed Installation Steps

Typical Gas Connection

Explains gas valve, flex lines, and connection considerations for a safe and efficient setup.

Operating the Fire Pit

General Operation Safety

Covers safety during operation, including hot surfaces, unattended use, and appropriate fuel types.

Lighting and Ignition Procedures

Step-by-step guide for safely lighting, operating, and turning off the fire pit.

Replacement Parts Identification

Parts Diagram and Overview

Parts List with Details

Maintenance and Troubleshooting

Troubleshooting Common Issues

Limited Warranty Information

Consumer Residential Warranty

Commercial Application Warranty

Warranty Claims and Exclusions

Technical Support Information

Technical Support Contact and Hours

Information Required for Support

Firegear FPB-19RBS16TPSI-N Specifications