Ford YT 16 User Manual

16 H.P. YARD TRACTOR (Gear Drive)
PAGE
INTRODUCTION AND SAFETY ................. 1
LUBRICATION AND MAINTENANCE ........... 2
ADJUSTMENTS AND SERVICING
Engine Remove
& Replace ................. 3
Electric (P.T.O.)
Clutch/Brake .............. 6
Adjustment
.......................... 6
Clutch Coil Check
.................... 6
Remove
& Replace ................... 7
Fuel Tank Remove & Replace .............. 9
Transaxle
Transaxle Remove
& Replace .......... 9
Traction Drive Brake Adjustment
..... 10
Brake Pad Replacement
.............. 10
Traction Drive Belt
..................... Belt Adjustment 11
.............. Belt Remove & Replace 11
Front Axle Remove
& Replace ............. 13
Steering Shaft Removal
................... 14
Steering Gear Adjustment
................. 15
Steering Sector Removal .................. 15
PAGE
......... Clutch/Brake Foot Pedal Removal 17
............. Clutch Pivot Bracket Removai 18
Traction Drive Gear Shift
....
Lever Adjustment (Ivlodel 09GN2151 only)
19
Traction Drive Gear Shift
....
Lever Adjustment (Model 09GN2151 onlyl
19
...... Attachment Lift Lever Shaft Removal 20
Throttle Control Lever Removal
........... 20
....................
Choke Cable Removal 21
Electrical System
System Functions
................... 22
Battery
............................. 24
.....................
Solenoid Check 24
Ammeter Check
..................... 25
............... Ignition Switch Check 26
Interlock Switch System Check
....... 26
Headlight Switch Check
............. 28
.............. Headlight Replacement 29
Fuse Replacement
................... 29
.......... P.T.O. Warning Light Check 29
Wiring Diagrams
.............. .3 0-30A
TROUBLE-SHOOTING
........................ 31
BOLT TORQUE SPECIFICATIONS
............. 32
IMPORTANT: The replacement of any part on this product by other than the
manufacturers'authorized replacemel
part may adversely affect the performance. durability or safety of this product .
The manufacturer reserves the right to make changes on and to add improvements upon its products at any tirr
without notice orobligation . The manufacturer also reserves the right to discontinue manufacture of any product
its discretion at any time
.
Notice to Serviceman in the State of California -The engine on this unit is NOT equipped with a spa
arresting muffler
.
IMPORTANT: USE OR OPERATION OF THIS ENGINE ON ANY FOREST COVERED . BRUSH COVERED. C
GRASS COVERED LAND
WITHOUTASTATEAPPROVEDSPARKARRESTOR IN EFFECTIVEWORKING ORDE
CONSTITUTES A VIOLATION OF THE LAW OF THE STATE OF CALIFORNIA
.
Furm No . 620-289
Rev . 1 :I85
Yard Tractor
Table Of Contents

Ford YT 16 Specifications

General

Brand	Ford
Model	YT 16
Category	Lawn Mower
Language	English

Summary

SAFETY

LUBRICATION AND MAINTENANCE

LUBRICATION

Details on engine oil checks, greasing points with specific grease types, and lubrication of pivot points.

ADJUSTMENTS AND SERVICING

ENGINE REMOVAL AND REPLACEMENT

Detailed steps for removing the engine, including disconnecting cables, fuel lines, and mounting hardware.

TRANSAXLE SERVICE

Procedures for transaxle removal, replacement, brake adjustment, and pad replacement.

FRONT AXLE REMOVAL AND REPLACEMENT

Procedure for removing and replacing the front axle, including steering linkage and pivot bolt steps.

STEERING SYSTEM SERVICE

Procedures for steering shaft removal, gear adjustment, and sector removal for proper operation.

CLUTCH AND BRAKE PEDAL SERVICE

Procedures for clutch/brake pedal and pivot bracket removal and service.

GEAR SHIFT LEVER ADJUSTMENT

Procedure to adjust the traction drive gear shift lever for proper gear engagement and neutral positioning.

CONTROL CABLE AND LEVER SERVICE

Procedures for throttle and choke cable/lever removal, replacement, and adjustment.

TRACTION DRIVE BELT

ELECTRICAL SYSTEM

SYSTEM FUNCTIONS

Explanation of the tractor's electrical system, including starting, ignition, and safety interlock functions.

BATTERY SERVICE

Information on battery type, warnings, first aid, charging, and removal procedures.

SOLENOID AND AMMETER CHECK

Procedures to check the starter solenoid and ammeter for proper operation and defects.

IGNITION AND INTERLOCK SWITCHES

Tests for ignition and safety interlock switches to ensure proper continuity and function.

LIGHTING AND WARNING SYSTEMS

Procedures for checking headlight switches, replacing headlights, fuses, and PTO warning light.

WIRING DIAGRAM (Model 09GN2151 S.N. YC 11780 and before)

WIRING DIAGRAM (Yard Tractor-Model 09GN2151 S.N. YC 11781 and after/and 09GN2152)

TROUBLE-SHOOTING

BOLT TORQUE SPECIFICATIONS