Giant UG30 Installation Instructions And Use & Care Guide

20
Water Temperature Regulation
Water temperature over 125°F (52°C)
can cause severe burns instantly
resulting in severe injury or death.
Children, the elderly, and the
physically or mentally disabled are at
highest risk for scald injury.
Feel water before bathing or
showering.
Temperature limiting valves are
available.
Read instruction manual for safe
temperature setting.
'XHWRWKHQDWXUHRIWKHW\SLFDOJDVZDWHUKHDWHUWKH
ZDWHUWHPSHUDWXUHLQFHUWDLQVLWXDWLRQVPD\YDU\XSWR
&)KLJKHURUORZHUDWWKHSRLQWRIXVHVXFKDV
EDWKWXEVVKRZHUVVLQNHWF
HOTTER WATER CAN SCALD: Water heaters are
intended to produce hot water. Water heated to a
WHPSHUDWXUHZKLFKZLOOVDWLVI\VSDFHKHDWLQJFORWKHV
washing, dish washing, and other sanitizing needs can
VFDOGDQGSHUPDQHQWO\LQMXUH\RXXSRQFRQWDFW6RPH
SHRSOHDUHPRUHOLNHO\WREHSHUPDQHQWO\LQMXUHGE\KRW
ZDWHUWKDQRWKHUV7KHVHLQFOXGHWKHHOGHUO\FKLOGUHQ
WKHLQILUPRUSK\VLFDOO\PHQWDOO\KDQGLFDSSHG,IDQ\RQH
XVLQJKRWZDWHULQ\RXUKRPHILWVLQWRRQHRIWKHVHJURXSV
RULIWKHUHLVDORFDOFRGHRUSURYLQFLDOODZUHTXLULQJD
FHUWDLQWHPSHUDWXUHZDWHUDWWKHKRWZDWHUWDSWKHQ\RX
must take special precautions. In addition to using the
ORZHVWSRVVLEOHWHPSHUDWXUHVHWWLQJWKDWVDWLVILHV\RXUKRW
ZDWHUQHHGVDPHDQVVXFKDVDPL[LQJYDOYHVKRXOGEH
XVHGDWWKHKRWZDWHUWDSVXVHGE\WKHVHSHRSOHRUDWWKH
ZDWHUKHDWHU0L[LQJYDOYHVDUHDYDLODEOHIURPDSOXPELQJ
VXSSO\VWRUHVHH)LJXUH)ROORZPDQXIDFWXUHU¶V
LQVWUXFWLRQVIRULQVWDOODWLRQRIWKHYDOYHV%HIRUHFKDQJLQJ
WKHIDFWRU\VHWWLQJRQWKHWKHUPRVWDWVHH)LJXUH8VLQJ
WKHORZHVWKRWZDWHUWHPSHUDWXUHWKDWPHHWV\RXUQHHGV
ZLOODOVRSURYLGHWKHPRVWHQHUJ\HIILFLHQWRSHUDWLRQRIWKH
water heater.
1HYHUDOORZVPDOOFKLOGUHQWRXVHDKRWZDWHUWDSRU
WRGUDZWKHLURZQEDWKZDWHU1HYHUOHDYHDFKLOGRU
KDQGLFDSSHGSHUVRQXQDWWHQGHGLQDEDWKWXERUVKRZHU
NOTE:$ZDWHUWHPSHUDWXUHUDQJHRI&&
))LVUHFRPPHQGHGE\PRVWGLVKZDVKHU
manufacturers.
7KHWKHUPRVWDWRIWKLVZDWHUKHDWHUKDVEHHQIDFWRU\VHW
DWLWVORZHVWSRVLWLRQ,WLVDGMXVWDEOHDQGPXVWEHUHVHW
to the desired temperature setting to reduce the risk of
VFDOGLQMXU\7KH
PDUNLVLQGLFDWLYHRIDSSUR[LPDWHO\
&)DQGDUHWKHSUHIHUUHGVWDUWLQJSRLQWVVHH
)LJXUH6RPHSURYLQFHVKDYHDUHTXLUHPHQWIRUDORZHU
setting.
7XUQWKHZDWHUWHPSHUDWXUHGLDOFORFNZLVH WR
GHFUHDVHWKHWHPSHUDWXUHRUFRXQWHUFORFNZLVH
WR
increase the temperature.
6KRXOGRYHUKHDWLQJRFFXURUWKHJDVVXSSO\IDLOWRVKXWRII
WXUQRIIWKHPDQXDOJDVFRQWUROYDOYHWRWKHDSSOLDQFH
Checking the Draft
WARNING
Burn Hazard
Do not touch vent.
Doing so can result in burns.
$IWHUVXFFHVVIXOO\OLJKWLQJWKHZDWHUKHDWHUDOORZWKHXQLWWR
operate for 15 minutes and check the draft hood relief
RSHQLQJIRUSURSHUGUDIW)LJXUH0DNHVXUHDOORWKHU
appliances in the area are operating and all doors are closed
when performing the draft test. Pass a match flame around
WKHUHOLHIRSHQLQJRIWKHGUDIWKRRG$VWHDG\IODPHGUDZQ
into the opening indicates proper draft.
M
ATCH
RELIEF
OPENIN
G
DRAFT HOOD
FIGURE 17.
,IWKHIODPHIOXWWHUVRULVEORZQRXWFRPEXVWLRQSURGXFWVDUH
escaping from the relief opening. If this occurs, do not operate
the water heater until proper adjustments or repairs are made
WRWKHYHQWSLSHV\VWHPDQGRUDLUVXSSO\UHTXLUHPHQWV
Burner Flames
,QVSHFWWKHEXUQHUIODPHVWKURXJKWKHYLHZSRUWDQG
FRPSDUHWKHPWRWKHGUDZLQJVLQ)LJXUH$SURSHUO\
RSHUDWLQJEXUQHUVKRXOGSURGXFHDVRIWEOXHIODPH%OXH
WLSVZLWK\HOORZLQQHUFRQHVDUHVDWLVIDFWRU\7KHWLSVRI
WKHIODPHPD\KDYHDVOLJKW\HOORZWLQW7KHIODPHVKRXOG
QRWEHDOO\HOORZRUKDYHDVKDUSEOXHRUDQJHFRORur.
&RQWDPLQDWHGDLUPD\FDXVHDQRUDQJHFRORured flame.
&RQWDFWDTXDOLILHGVHUYLFHWHFKQLFLDQLIWKHIODPHLVQRW
VDWLVIDFWRU\
FIGURE 18.
Emergency Shut Down
,03257$176KRXOGRYHUKHDWLQJRFFXURUWKHJDVVXSSO\
IDLOVWRVKXWRIIWXUQRIIWKHZDWHUKHDWHU¶VPDQXDOJDV
FRQWUROYDOYHDQGFRQWDFWDTXDOLILHGVHUYLFHWHFKQLFLDQ

Giant UG30 Specifications

General

Brand	Giant
Model	UG30
Category	Water Heater
Language	English