Giant UG30 Installation Instructions And Use & Care Guide

8
,03257$177KLVZDWHUKHDWHUPXVWEHLQVWDOOHGVWULFWO\LQ
DFFRUGDQFHZLWKWKHLQVWUXFWLRQVHQFORVHGDQGDOODSSOLFDEOH
HOHFWULFDOIXHODQGEXLOGLQJFRGHV,WLVSRVVLEOHWKDW
connections to the water heater, or the water heater itself,
PD\GHYHORSOHDNV,WLVWKHUHIRUHVWURQJO\UHFRPPHQGHG
WKDWWKHZDWHUKHDWHUEHLQVWDOOHGVRWKDWDQ\OHDNDJHRI
the tank or related water piping is directed to an adequate
GUDLQLQVXFKDPDQQHUWKDWLWFDQQRWGDPDJHWKHEXLOGLQJ
IXUQLWXUHIORRUFRYHULQJDGMDFHQWDUHDVORZHUIORRUVRIWKH
VWUXFWXUHRURWKHUSURSHUW\VXEMHFWWRZDWHUGDPDJH7KLVLV
SDUWLFXODUO\LPSRUWDQWLIWKHZDWHUKHDWHULVLQVWDOOHGLQDPXOWL
VWRU\EXLOGLQJRQILQLVKHGIORRULQJRUFDUSHWHGVXUIDFHV7+(
MANUFACTURER WILL NOT ASSUME ANY LIABILITY
IRUGDPDJHFDXVHGE\ZDWHUOHDNLQJIURPWKHZDWHUKHDWHU
SUHVVXUHUHOLHIYDOYHRUUHODWHGILWWLQJV6HOHFWDORFDWLRQ
DVFHQWUDOL]HGZLWKLQWKHSLSLQJV\VWHPDVSRVVLEOH,QDQ\
ORFDWLRQVHOHFWHGLWLVUHFRPPHQGHGWKDWDVXLWDEOHGUDLQSDQ
EHLQVWDOOHGXQGHUWKHZDWHUKHDWHU7KLVSDQPXVWOLPLWWKH
ZDWHUOHYHOWRD0$;,080GHSWKRIPPLQDQG
KDYHDGLDPHWHUWKDWLVDPLQLPXPRIPPLQJUHDWHU
WKDQWKHGLDPHWHURIWKHZDWHUKHDWHU6XLWDEOHSLSLQJVKDOO
FRQQHFWWKHGUDLQSDQWRDSURSHUO\RSHUDWLQJIORRUGUDLQ
8QGHUQRFLUFXPVWDQFHVLVWKHPDQXIDFWXUHUWREHKHOG
UHVSRQVLEOHIRUDQ\ZDWHUGDPDJHLQFRQQHFWLRQZLWKWKLV
water heater. When used with a fuel-fired heater, this drain
SDQPXVWQRWUHVWULFWFRPEXVWLRQDLUIORZ
METAL
DRAIN
PAN
AT LEAST 2” (50.8 mm) GREATER THAN
THE DIAMETER OF THE WATER HEATER.
PIPED TO AN
ADEQUATE DRAIN
12” (300 mm)
MAXIMUM AIR GAP
DISCHARGE PIPE
(DO NOT CAP OR PLUG)
FIGURE 2.
:DWHUKHDWHUOLIHGHSHQGVXSRQZDWHUTXDOLW\ZDWHUXVDJH
ZDWHUWHPSHUDWXUHDQGWKHHQYLURQPHQWLQZKLFKWKH
water heater is installed. Water heaters are sometimes
LQVWDOOHGLQORFDWLRQVZKHUHOHDNDJHPD\UHVXOWLQSURSHUW\
GDPDJHHYHQZLWKWKHXVHRIDPHWDOGUDLQSDQSLSHGWRD
GUDLQ+RZHYHUXQDQWLFLSDWHGGDPDJHFDQEHUHGXFHGRU
SUHYHQWHGE\DOHDNGHWHFWRURUZDWHUVKXWRIIGHYLFHXVHG
LQFRQMXQFWLRQZLWKDSLSHGPHWDOGUDLQSDQ7KHVHGHYLFHV
DUHDYDLODEOHIURPVRPHSOXPELQJVXSSO\ZKROHVDOHUVDQG
UHWDLOHUVDQGGHWHFWDQGUHDFWWROHDNDJHLQYDULRXVZD\V
• Sensors mounted in the metal drain pan that trigger an
alarm or turn off the incoming water to the water heater
when water is detected.
• Sensors mounted in the metal drain pan that turn off the
ZDWHUVXSSO\WRWKHHQWLUHKRPHZKHQZDWHULVGHWHFWHGLQ
the metal drain pan.
 :DWHUVXSSO\VKXWRIIGHYLFHVWKDWDFWLYDWHEDVHGRQWKH
ZDWHUSUHVVXUHGLIIHUHQWLDOEHWZHHQWKHFROGZDWHUDQGKRW
water pipes connected to the water heater.
 'HYLFHVWKDWZLOOWXUQRIIWKHJDVVXSSO\WRDJDVZDWHU
KHDWHUZKLOHDWWKHVDPHWLPHVKXWWLQJRIILWVZDWHUVXSSO\
REVERSE FLOW
OF GASES
EXHAUST FAN
FIGURE 3.
Clearances And Accessibility
127(0LQLPXPFOHDUDQFHVIURPFRPEXVWLEOHVXUIDFHVDUH
VWDWHGRQWKHUDWLQJSODWHDGMDFHQWWRWKHJDVFRQWUROYDOYH
thermostat of the water heater.
The water heater is certified for installation on a
FRPEXVWLEOHIORRU
• ,03257$17,ILQVWDOOLQJRYHUFDUSHWLQJWKHFDUSHWLQJ
PXVWEHSURWHFWHGE\DPHWDORUZRRGSDQHOEHQHDWK
WKHZDWHUKHDWHU7KHSURWHFWLYHSDQHOPXVWH[WHQG
EH\RQGWKHIXOOZLGWKDQGGHSWKRIWKHZDWHUKHDWHUE\
DWOHDVWPP´LQDQ\GLUHFWLRQRULILQDQDOFRYHRU
FORVHWLQVWDOODWLRQWKHHQWLUHIORRUPXVWEHFRYHUHGE\
the panel.
• )LJXUHPD\EHXVHGDVDUHIHUHQFHJXLGHWRORFDWH
the specific clearance locations. A minimum of 610mm
´RIIURQWFOHDUDQFHVKRXOGEHSURYLGHGIRULQVSHF-
WLRQDQGVHUYLFH
BACK
SIDES
TOP
VIEW
SIDES
VENT
FRONT
24 in
(609.6 mm)
MINIMUM
FOR SERVICE
TOP
TO
CEILING
FIGURE 4.

Giant UG30 Specifications

General

Brand	Giant
Model	UG30
Category	Water Heater
Language	English