EasyManua.ls Logo

Gold Uniflame GBC1069WB-C - User Manual

Gold Uniflame GBC1069WB-C
28 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
Outdoor LP Gas Barbecue Grill
Model No. GBC1069WB-C
Manufactured in China for: Blue Rhino Global Sourcing, Inc
Winston-Salem, NC USA • 1.800.762.1142, www.bluerhino.com
© 2010 Blue Rhino Global Sourcing, Inc. All Rights Reserved
UniFlame
®
is a Registered Trademark of Blue Rhino Global Sourcing, Inc.. All Rights Reserved. GBC1069WB-C-OM-102 EF
WARNING
FOR YOUR SAFETY:
1. Improper installation, adjustment, alteration,
service or maintenance can cause injury or
property damage.
2. Read the installation, operation and
maintenance instructions thoroughly before
installing or servicing this equipment.
3. Failure to follow these instructions could
result in fire or explosion, which could cause
property damage, personal injury or death.
Save these instructions for future reference.
If you are assembling this unit for someone else,
give this manual to him or her to read and save
for future reference.
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
Table of Contents
Important Safeguards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 2
Exploded View & Hardware. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Assembly Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Installling LP Gas Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Insert LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Secure LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Connect LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Disconnect LP Gas Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Installling Natural Gas Line . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Operating Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Checking for Leaks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Operating Main Burners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Operating Sear Burner. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Operating Infrared Back Burner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Operating the Digital Timer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Cleaning and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Product Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
The use and installation of this product must conform to local codes. In absence
of local codes, use the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas
and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code,
B149.2.
GOLD
OWNER’S MANUAL
Made from 70% Bagasse
(Environmentally Friendly Sugar
Cane Pulp By-product)
Natural gas conversion
kit is available, model
number VFK1000W-C.

Table of Contents

Questions and Answers

  • M
    martharussellAug 19, 2025
    What to do if Gold Uniflame Grill burner will not light with match?
    • J
      Jeremy EvansSep 12, 2025
      If the Gold Uniflame Grill burner won't light with a match, there could be several reasons. First, ensure there is gas flow. If using LP, check if the tank is empty and replace or refill if needed. If the tank isn't empty or if using NG, refer to “Sudden drop in gas flow or reduced flame height”. Also, check for gas leaks by closing the gas tank/main valve, waiting 5 minutes, and following the leak-checking procedure in the owner’s manual. Ensure the coupling nut and regulator are fully connected, tightening by hand only. Clear any obstructions in the burner tubes and check for bent or kinked hoses. Make sure the burner is properly engaged with the valve, and clean the venturi and burner tube if there are spider webs or insect nests. Lastly, clean any clogged or blocked burner ports.
  • M
    Michael ReidAug 25, 2025
    Why is the inside of my Gold Uniflame Grill lid peeling?
    • M
      Mary MoyerAug 26, 2025
      If the inside of your Gold Uniflame Grill lid is peeling, it's likely due to baked-on grease buildup that has turned to carbon and is flaking off. Thoroughly clean the lid following the “Cleaning and Care” instructions in the owner’s manual. If, after cleaning, you can see steel, contact Customer Care at 1.800.762.1142.
  • C
    cfowlerAug 28, 2025
    How to stop flare-ups on Gold Uniflame GBC1069WB-C?
    • K
      Kristen ParsonsAug 28, 2025
      If your Gold Uniflame Grill is experiencing flare-ups, it's often due to grease buildup. To resolve this, remove and clean all grill parts according to the “Cleaning and Care” instructions in the owner’s manual. Other causes could be excess fat in the meat, so trim the fat before grilling. Also, excessive cooking temperature can cause flare-ups, so adjust the temperature to a lower setting.
  • V
    vbakerAug 31, 2025
    Why is the flame pattern irregular on my Gold Uniflame GBC1069WB-C?
    • C
      cindyromanAug 31, 2025
      An irregular flame pattern on your Gold Uniflame Grill, where the flame doesn't run the full length of the burner, is typically caused by clogged or blocked burner ports. Clean the burner ports to resolve this issue.
  • H
    Henry GoodwinSep 3, 2025
    Why is the flame yellow or orange on my Gold Uniflame Grill?
    • V
      Victoria BraunSep 3, 2025
      If the flame on your Gold Uniflame Grill is yellow or orange, it could be due to several reasons. If it's a new burner, it may have residual manufacturing oils; burn the grill for 15 minutes with the lid closed to resolve this. Spider webs or insect nests in the venturi can also cause this issue, so clean the venturi. Food residue or grease on the burner can also be a factor, so clean the burner. Lastly, poor alignment of the valve to the burner venturi can cause a yellow or orange flame; ensure the burner venturi is properly engaged with the valve.
  • A
    Anthony JacksonSep 6, 2025
    What to do if the flame keeps blowing out on my Gold Uniflame GBC1069WB-C Grill?
    • T
      Thomas GarciaSep 6, 2025
      If the flame on your Gold Uniflame Grill blows out, it could be due to high or gusting winds; avoid using the grill in such conditions. It could also be due to low LP gas, so replace or refill the LP gas tank. Finally, the excess flow valve may have tripped; refer to “Sudden drop in gas flow or reduced flame height” to resolve this.
  • N
    nwalkerSep 9, 2025
    How to handle a persistent grease fire in my Gold Uniflame GBC1069WB-C Grill?
    • R
      richardrojasSep 9, 2025
      A persistent grease fire on your Gold Uniflame Grill is likely due to grease trapped by food buildup around the burner system. To address this, first turn the control knobs to OFF and close the LP gas tank valve or NG main valve. Leave the lid closed and let the fire burn out. Once the grill cools, remove and clean all parts following the “Cleaning and Care” instructions in the owner’s manual.
  • D
    Dylan CamachoSep 12, 2025
    What causes flashback in the burner tubes of my Gold Uniflame GBC1069WB-C Grill?
    • B
      Brian McconnellSep 12, 2025
      Flashback (fire in the burner tube(s)) in your Gold Uniflame Grill is usually caused by blocked burner and/or burner tubes. Clean the burner and/or burner tubes to resolve this issue.
  • M
    Michael BarrettNov 15, 2025
    How to fix Gold Uniflame GBC1069WB-C burner that won't light using ignitor?
    • F
      festesNov 15, 2025
      If the Gold Uniflame Grill burner won't light with the ignitor, several issues could be the cause. First, ensure the LP gas tank valve or NG main valve is open and securely attached. If using LP, make sure the tank isn't low or empty, and replace or refill it if needed. Check for any gas leaks and follow the leak-checking procedure in the owner's manual after closing the valve and waiting five minutes. Also, inspect the wires and electrode for cooking residue and clean them with rubbing alcohol if necessary. Ensure the electrode and burners are dry, wiping them with a cloth if wet. Finally, check for damaged or loose components, replacing the electrode if cracked or broken, reconnecting any loose wires, or replacing the ignitor wire/electrode assembly if shorting. If the ignitor is bad, re...
  • S
    Stacey MullinsNov 21, 2025
    Why is gas flow suddenly dropping on my Gold Uniflame GBC1069WB-C Grill?
    • J
      joshuawrightNov 21, 2025
      If you experience a sudden drop in gas flow or reduced flame height on your Gold Uniflame Grill, it could be due to several reasons. If using LP, the tank may be out of gas and needs to be replaced or refilled. If using NG, there might be no main line pressure, in which case you should contact your Natural Gas provider to inspect the line. For LP users, an excess flow safety device may have been activated. To reset it, turn the control knobs to OFF, wait 30 seconds, and try lighting the grill again. If the flames are still too low, fully reset the device by turning the control knobs OFF, closing the LP gas tank valve, disconnecting the regulator, turning the control knobs to HIGH, waiting 1 minute, turning the control knobs OFF, reconnecting the regulator (and leak checking), and slowly op...

Summary

Safety Warnings

Outdoor Use and Enclosure Safety

Installation and Operation Safety

Details on safe installation, adjustment, alteration, service, and maintenance to prevent injury.

Safety Precautions and Warnings

Gas Leak Detection and Response

Instructions for detecting gas leaks and immediate actions to take.

LP Gas Tank Safety and Handling

Covers LP gas characteristics, tank requirements, storage, handling, and valve safety.

Natural Gas Conversion and Safety

Operational Safety Guidelines

General rules for safe operation including leak testing, maintenance, and fire safety.

Installing Gas Supply

Installing LP Gas Tank

Steps for inserting, securing, connecting, and disconnecting the LP gas tank.

Installing Natural Gas Line

Instructions for connecting and disconnecting the natural gas line.

Operating Instructions

Checking for Leaks

Procedures for checking gas connections for leaks using a soap solution.

Operating Main Burners

Controlling Flare-ups

Operating Sear Burner

Operating Infrared Back Burner

Troubleshooting Common Issues

Burner Ignition Problems

Solutions for when the burner will not light using ignitor or match.

Flame and Gas Flow Issues

Addresses sudden drop in gas flow, irregular flame patterns, and flame blow out.

Fire and Burner Tube Issues

Gold Uniflame GBC1069WB-C Specifications

General IconGeneral
BrandGold Uniflame
ModelGBC1069WB-C
CategoryGrill
LanguageEnglish

Related product manuals