Home
Hamilton
Payment Terminal
HTK Pay Station
Hamilton HTK Pay Station - User Manual
36 pages
Manual
Specs
Ask a question
Save Page as PDF
To Next Page
To Next Page
Loading...
P
A
Y ST
A
TION
INST
ALLA
TION MANUAL
Car W
ash Application
Hamilton Manufacturing Corp.
P: 419.867.4852 | P: 888.723.4858 | F: 419.867.4850
www
.hamiltonmfg.com
Version 2.0 | 10/20
Document # 101-0204
HTK
2
Table of Contents
Main Page
Default Chapter
3
Table of Contents
3
Introduction
5
About this Manual
5
Warranty Card
5
Dedicated Power Source
5
Mechanical Installation
6
Receiving and Unpacking HTK
6
Figure 1.1: HTK Pallet (Face)
6
Figure 1.2: HTK Pallet (Side)
6
Positioning
7
Mounting
7
Running Conduit
7
Dimensions: Brick-In Cabinet
8
Figure 2.1: Top of Cabinet
8
Figure 2.2: Base of Cabinet
8
Figure 2.3: Side of Cabinet
9
Figure 2.4: Rear of Cabinet
9
Figure 2.5: Door
10
Brick-In Bolt Pattern
11
Figure 3.1: Brick-In HTK Bolt Pattern
11
Dimensions: Free-Standing Cabinet
12
Figure 4.1: Top of Cabinet
12
Figure 4.2: Base of Cabinet
12
Figure 4.3: Sides of Cabinet
13
Figure 4.4: Rear of Cabinet
13
Figure 4.5: Door & Base of HTK
13
Free-Standing Bolt Pattern
14
Figure 5.1: Free-Standing HTK Bolt Pattern
14
Lane Layout (When Using Gates)
15
Figure 6.1: Front View of Brick-In Lane Layout
15
Figure 6.2: Front View of Free-Standing Lane Layout
15
Figure 6.3: Overhead View of Lane Layout
16
Figure 6.4: Service Door Orientation
16
Electrical Installation
17
Pulling Wires
17
Wire Terminations
18
Electrical Diagrams
20
Figure 7.1: Power Supply Wiring Connection
20
Figure 7.2: Wash Interface Diagram
21
Figure 7.3: Wash Interface Diagram, Angled
21
Figure 7.4: Gated Sequence Software Ether Vend (MIB Gate)
22
Figure 7.5: Gated Sequence Software Ether Vend (Micro Drive Gate)
23
Car Wash Cycle Synchronization: Active or Passive
24
Figure 7.6: Passive Cycles
24
Figure 7.7: Active Cycles
24
Component Connections
25
Power Supply
25
Figure 8.1: Power Supply Connections
25
Controller
26
Figure 8.2: Gen5 Controller Connections
26
Figure 8.3: Gen4 Controller Connections
27
Figure 8.4: Gen3 Controller Connections
28
Distribution Board
29
Figure 8.5: Distribution Board Connections
29
Smart Bus Hub
30
Figure 8.6: Smart Bus Hub Connections
30
Bill Dispenser
31
Figure 8.7: Bill Dispenser Connections
31
Stacker Interface
32
Figure 8.8: Stacker Interface Connections
32
Gate & Loop References
33
References
33
Warranty
34
Limited Warranty Agreement
34
Need help?
Do you have a question about the Hamilton HTK Pay Station and is the answer not in the manual?
Ask a question
Hamilton HTK Pay Station Specifications
General
Brand
Hamilton
Model
HTK Pay Station
Category
Payment Terminal
Language
English
Need help?
General
To Next Page