Hansen APPT08 - Parts Identification

27
APP-001f
SEPT 2016
*Serial Number CC185 (2008) or earlier, APPT PLC program must be updated to work with current module
Theremoterelayisadrycontactthatisnormallyopenduringnon‐signalingconditions.Theremote
relaycanswitchupto1A@240VAC.

Conditionsthattriggertheremoterelay:
1. ERROR2222
2. ERROR3333
3. ERROR4444
4. ERROR7777
5. HEATERFAULTorSERVICEREQUIRED
6. READYTODRAIN

RefertoFigure8forwiringdetails”TOTOPOFRIGHTHANDCOLUMN
Page15
1. AddFigure8–RemoteRelaywiring
Page16
1. Removecurrenttable,addtablesbelow
MECHANICAL
20‐1018 Kit,FloatSwitchHLLSW,LongLeadsforPurger
20‐1772 WaterBubblerAssembly,antisyphon(w/endconnections)
20‐1186 MeteringValve
20‐1198 Kit,MeteringValveSeal
20‐1648 MeteringValveStrainer
20‐1737 Kit,ScreenAssemblyReplacementforabovestrainer,includes:
20‐1535–ScreenAssembly
78‐0016–StrainerCapGasket
ST050 WaterPurgeLineStrainer
78‐1001 Kit,ScreenAssemblyReplacementforabovestrainer,includes:
78‐0005–ScreenAssembly
78‐0016–StrainerCapGasket
70‐1059 PlungerKitforallAPPSolenoidValves
20‐1183 CheckValve,1psid(.07bar)withorifice
20‐2489 CheckValve,1psid(.07bar)noorifice
20‐1185 CheckValve,225psid(15.5bar)
20‐1214 Kit,CheckValveSealfor1psidand225psidCheckValves
20‐1311 LiquidDrainer
20‐2432 VaporTrap
H5600R/300 ReliefValve,300psi
HS2/3 HS2SolenoidValve(lesscoil),½”FPT(solenoidB,F)
HS2/1 HS2SolenoidValve(lesscoil),¼”FPT(solenoidC)
HS2B/1 HS2(Brass)WaterSolenoidValve(lesscoil),¼”FPT(solenoidD)
HS2F/1 HS2SolenoidValve(lesscoil),Flanged(solenoidG)
HS8A/1 HS8SolenoidValve(lesscoil),Flanged(solenoidE)
70‐1101 Kit,AmberBeaconLight,(solenoidC,D)
70‐1102 Kit,GreenBeaconLight,(solenoidB,E,F,G)

ELECTRICAL
70‐1088 SolenoidCoil,DINplug–115V,50/60Hz,16Watt
20‐2428 ElectricHeater,115V,50/60Hz,750Watt
20‐2477 ElectricHeater,230V,50/60Hz,750Watt
20‐2620 Kit,Fuse,2amp,115Vpurger
20‐2621 Kit,Fuse,15amp,115Vpurger
20‐2622 Kit,Fuse,3amp,230 Vpurger
20‐2623 Kit,Fuse,8amp,230 Vpurger
20‐2626* Kit,PLCModule,ThermocoupleInput,Enhanced,EZ10-4THIE
20‐2627 Kit,PLCModule,CurrentInput,EZ10-8ANICO
20‐2628 Kit,PLCModule,ACOutput,EZ10-8ACO
20‐2629 Kit,PLCModule,ACInput/Output,EZ10-4 ACI 4ACO
20‐2631 Kit,PLCModule,ACInput,APP24‐2,APPT24‐2, EZ10-8ACI
20‐2410 HeaterContactor
20‐2411 Cable,PLCtoControlConsole
PSU 100‐240VAC:24VDCPowerSupply
HPT717 WaterConcentrationSensor
SPSN‐1 LiquidMake‐upLevelSensor,LowLiquidLevelSensor
20‐2429 Thermocouple,PlateTemperature
20‐2430 Thermocouple,LiquidTemperature
20‐2431 Thermocouple,EvaporatorShellTemperature
PT1 PressureTransducer
20‐2464 Transformer220V/115V

CONTROLLERS
 V PLC APPT Touch Screen
115 20‐2624 20‐2580
APP08
230 20‐2640 20‐2581
115 20‐2632 20‐2582
APP16
230 20‐2641 20‐2583
115 20‐2638 20‐2584
APP24
230 20‐2642 20‐2585
115 20‐2625 20‐2578
APPC
230 20‐2639 20‐2579

Page17
*“20”mightneedtochange,mustbelastpageofbulletin
Page18
SECTION 5 SERVICE, TROUBLESHOOTING, & PARTS
(20-2406)
(20-2407)
(20-2408)
Kit, PLC Module, Thermocouple Input, Enhanced, EZ10-4THIE(20-2405)
Kit, PLC Module, AC Input,APP24-2, APPT24-2, EZ10-8ACI (20-2404)
APPT Color Touchscreen
APPT08
APPT16
APPT24
APPTC