Helo 1601-31-1 User Manual

INSTALLATION AND OPERATING INSTRUCTIONS
72-0106 01-07-16 7013482 314 SKSM 215 A
Page 1
WARNING
SECTION 1: GENERAL INFORMATION
Do not take a sauna if using
alcohol, drugs or
medications.
Pregnant women or persons
with poor health should
consult their physician before
using any sauna.
Caution re hazard: Do not
use the sauna room for
drying clothes, bathing suits,
etc. Do not hang towels
above heater or place any
object other than the rocks
supplied on the heater. If any
darkening of the wall around
the heater is noticed
discontinue sauna use
immediately.
Inspect sauna regularly for
required maintenance to
heater, control and benches.
Replace wood surfaces
which show any signs of
deterioration.
The heater gets extremely hot
during operation and should
not be touched or burns may
result.
Minors should be adequately
supervised whenever near a
hot or warming sauna.
Designer “Trend" Series Sauna Heaters
Models 4.5, 6.0, 8.0
(Type #'s 1712-45-1706, 1712-60-1706, 1712-80-1706)
with Trend Control (Type # 1601-31 and 1601-31-1).
Read all instructions carefully before installation. Please leave all
instructions and warranty with the owner.
WARNING
Prolonged exposure to elevated temperatures is capable of inducing
hyperthermia. Hyperthermia occurs when the internal temperature of the
body reaches several degrees above the normal body temperature of
98.6°F. The symptoms of hyperthermia include an increase in the normal
temperature of the body, dizziness, lethargy, drowsiness, and fainting. The
effects of the hyperthermia include failure to perceive heat, failure to
recognize the need to exit the room, unawareness of impending hazard,
fetal damage in pregnant women, physical inability to exit the room and
unconsciousness.
WARNING
The use of alcohol, drugs, or medication is capable of greatly increasing
the risk of fatal hyperthermia.
These heaters are ETL approved by Intertek for permanent installations and
electrical connections. Built with splash proof construction, the conducting
parts are protected against water. All wiring must be performed in
accordance with national and local codes. See Diagram 2 for wire and
room size requirements. These heaters are wall mounted.

Helo 1601-31-1 Specifications

General

Brand	Helo
Model	1601-31-1
Category	Heater
Language	English

Summary

General Information and Safety

General Information

Overview of heater approval, construction, and electrical connection requirements according to codes.

Key Safety Warnings

Crucial safety precautions regarding alcohol, drugs, health, and fire hazards in the sauna environment.

Heater Mounting and Clearances

Mounting Bracket Location and Distances

Instructions for attaching the heater to the wall, ensuring proper clearances to combustible materials.

Placing of Rocks

Electrical Hook-Up

Temperature Sensor Installation

Heater Screen (Guard Rail)

Control Installation & Operation

Control Installation Rough-In

Procedures for placing the control unit and routing the low-voltage cable within the sauna room structure.

Control Operation Guide

Instructions on how to use the control panel for lighting, setting sauna length, and adjusting temperature.

Heater Operation and High Limit Reset

Starting and Stopping the Heater

How to start the heater immediately or use the time delay feature, and how to turn it off.

High Limit Control (Reset Button)

How to Take a Sauna

Room Construction and Ventilation

Warning Placards

Instructions for attaching "CAUTION" and "WARNING" placards in their designated locations.

Room Construction

Rules for sauna room construction, including door operation, lighting, and intercoms for safety.

Ventilation

Guidance on achieving proper air changes per hour using specific vent formulas based on room size.

Maintenance

Troubleshooting and Fault Codes

Fault Code Interpretation

Detailed list of constant and flashing LED fault codes and their corresponding issues for diagnosis.