Hoshizaki KMD-410MAH Cleaning & Sanitizing

Cleaning Prep:
Remove the Front Panel, move the control switch to
OFF. After 3 min., move the control switch to ICE, then
replace the Front Panel .
After 3 min., remove the Front Panel, move the
control switch to OFF. This removes the cubes from
the evaporator. Replace the Front Panel.
Remove all ice from the dispenser unit/ice storage bin.
ATTENTION! IF ON DISPENSER, turn off the dispenser power
supply after dispensing all the ice.
Cleaning:
Remove the Front Panel, move the service switch to
DRAIN. Move control switch to SERVICE. Replace the
Front Panel.
After 2 minutes, remove the Front Panel, move the
control switch to OFF.
Dilute Hoshizaki Scale Away with warm water (see Table below).
Remove the Insulation Panel (A) and pour cleaning solution into
the water tank.
KMD-410, 460, 530
Scale Away
9.5 fl. oz (281 ml)
Warm Water
1.8 gal. (6.8 l)
In bad water conditions, a more thorough cleaning may
be required. Move control switch to OFF, then turn off
the power supply. Dilute 5 oz. of Scale Away to 1
gallon of warm water. Remove and clean the float
switch assembly (see Float Switch Cleaning on back),
water supply tubes, spray tubes, water tank, and pump
motor and float switch assembly. Rinse thoroughly,
then replace in their correct positions. Turn the power
supply back on. Otherwise, continue to Step ❽.
Ice Machine
KMD-410MAH, MWH, MRH
KMD-460MAH, MWH, MRH
KMD-530MAH, MWH, MRH
Sanitizing:
• Dilute 5.25% chlorine
bleach* with warm water
(see Table below)
KMD-410, 460, 530
Bleach
0.9 fl. oz (27 ml)
Warm Water
1.8 gal. (6.8 l)
* Use bleach without additives.
• Remove the front panel &
insulation panel (A)
• Pour the sanitizing solution
into the water tank
• Replace all the panels, except
the front panel
• Move service switch to
WASH and control switch to
SERVICE, replace the front
panel
• After 15 minutes, remove
front panel
• Move service switch to DRAIN,
replace the front panel
• After 2 minutes, remove
front panel
• Move control switch to OFF
3
min.
3
min.
Cleaning & Sanitizing
AMMONIA
Cleaners
The icemaker must be cleaned & sanitized at least once a year.
ATTENTION!
Do not leave icemaker
unattended when panels are off
 continued on the back…
Tech Support: 1.800.233.1940
1
2
3
4
15
16
17
18
19
5
6
After 2 min.
7
Top
Service Switch
Control Switch
Water Tank
Right
Side
Front of icemaker
Insulation Panel (B)
Thumbscrews
Tech Support: 1.800.233.1940
Page 1
#51009 | 4.28.2017

Hoshizaki KMD-410MAH Specifications

General

Condenser Type	Air-cooled
Refrigerant	R-404A
Voltage	115V
Phase	1
Hertz	60Hz
Type	Modular
Ice Type	Crescent Cube
Water Supply	Potable water
Ice Production Capacity	410 lbs/day