This document is an instruction manual for the Spider-Man 6-volt Motorbike, an electric ride-on toy. It provides comprehensive information regarding its assembly, usage, maintenance, and safety precautions.
Function Description
The Spider-Man 6-volt Motorbike is a ride-on toy designed for children, allowing them to operate a miniature motorbike. It features a forward gear only, controlled by a start/go switch on the right handlebar. The dashboard includes buttons for horn and engine sounds, powered by two AA batteries (not provided). The motorbike is equipped with training wheels for stability and a thermal overload fuse for safety, which cuts off power for 10-20 seconds if the bike is overloaded.
Important Technical Specifications
- Item No.: 55180
- Model No.: ZP3999B
- External Dimensions: 107x53x70 cm
- Ages: Suitable for children 3 years and older
- Max Weight Limit: 30 kg
- Speed: 2.5-3 km/hr
- Power Mode: Rechargeable
- Fuse Spec: 5 amp Thermal Fuse
- Charging Time: 8-12 hours (10-14 hours for the first charge)
- Charging Spec: 8V 0.5A
- Battery Spec.: 6V, 4.5AH
- Number of Riders: Only 1 rider at a time
- Gear: Forward gear only
Usage Features
The motorbike is designed for ease of use with a simple start/go switch. Before first use, the battery needs to be charged for 10-14 hours. Subsequent charges should be 8-10 hours, but never more than 15 hours. The charging port is located on the right side of the bike. The dashboard requires two AA batteries for the horn and engine sounds.
Safety Precautions and Warnings:
- Adult assembly is required.
- Keep small children away during assembly and dispose of packaging properly.
- Riders must always wear a fitted helmet that complies with Australian Standard AS/NZS 2063:2008.
- Battery posts, terminals, and related accessories contain lead and lead compounds; never open the battery.
- Keep body parts, hair, and clothing away from moving parts. Always wear shoes.
- Do not use near streets, motor vehicles, drop-offs (steps, water, sloped surfaces, hills), wet areas, flammable vapors, in alleys, at night, or in the dark.
- Always use in a safe, secure environment with continuous adult supervision.
- Avoid unsafe conditions like snow, rain, loose dirt, mud, sand, or fine gravel.
- Do not pull the vehicle with another device, allow more than one rider, push from the back, or travel at an unsafe speed.
- Always use common sense and safe practices; do not mix different types of batteries or new and old batteries.
- Not to be used in traffic.
- Unsuitable for children under 3 years due to maximum speed.
- Periodically check the battery charger, electric wire plug enclosure, and other parts for damage.
- Additional hazards exist when using the toy in areas other than private grounds.
- Never leave a child unattended; direct adult supervision is required.
- Always sit on the seat.
- Risk of fire; do not bypass.
- Only drive on level ground.
- Do not go near water, drop-offs, or steep slopes.
- Do not drive into loose dirt, mud, or fine gravel.
- Use only the supplied 6V rechargeable battery and charger to prevent fire or explosion.
- Charge the battery in a well-ventilated area, away from heat or flammable materials, as explosive gases are created during charging.
- Avoid contact between positive and negative terminals to prevent fire or explosion. Pick up the battery by its case or handles, not by wires.
- Keep all liquids away from the battery.
- In case of battery leakage, immediately call a physician. Flush skin/eyes with cool water for 15 minutes. If swallowed, give water or milk (do not induce vomiting if patient is vomiting or has decreased alertness).
- Tampering with the electric circuit system can cause shock, fire, or explosion. Keep charger housing closed.
- Non-rechargeable batteries are not to be recharged.
- Batteries must be inserted with correct polarity.
- Exhausted batteries must be removed.
- Supply terminals are not to be short-circuited.
- Rechargeable batteries are only to be charged under adult supervision.
Maintenance Features
- Regularly inspect all vehicle parts, charger, cord, and plug for damage.
- Remove damaged parts immediately and contact Customer Service for replacements.
- DO NOT operate if any parts are damaged.
- Clean with a damp cloth and mild soap; avoid getting water near electrical parts. Do not wash with a hose.
- Store indoors or cover with a tarp, away from stoves, heaters, or other heat sources.
- Charge the battery immediately after each use for 8-12 hours (max 15 hours).
- Charge the battery at least once a month, even if not in use.
- Never leave the battery in a discharged condition.
- Disconnect the battery connector from the engine connector before storing for extended periods.
- If the charger heats above 71°C / 160°F, disconnect and call Customer Service.
- Keep the charger away from water or excessive moisture.
- Use only the specified charger; do not charge with any other charger.
- Do not attempt to recharge non-rechargeable batteries.
- Do not replace the battery with any other battery, as this voids the warranty.
- Remove damaged batteries immediately and dispose of them responsibly.
- Do not short circuit supply terminals.
- The thermal fuse will reset itself after 10-20 seconds if tripped. To avoid tripping, ensure the user weight is within limits, do not tow or overload, keep electric components dry, and do not alter the bike's circuitry or construction.
Troubleshooting Guide
The manual includes a detailed troubleshooting guide covering issues such as the vehicle not running, running for a short time, running slowly, difficulty shifting, grinding noises from the motor/gearbox, and battery not recharging. Solutions range from recharging the battery and resetting the fuse to tightening connections, replacing parts, reducing weight, and contacting customer service.
For after-sales service, replacement parts, or general inquiries, customers can visit www.electricrideon.com.au, call the Toll Free Service Phone at 1800 224 094, or email enquiries@hunterproducts.com.au. Service hours are Monday to Friday, 9:00 AM - 5:00 PM (AEST).
Warranty
Hunter Products offers a one-year limited warranty on the Spider-Man 6v Motorbike (excluding the 6-volt battery) for defects in materials and workmanship from the date of purchase. The warranty is valid if the product is correctly assembled and used according to instructions. Hunter Products may offer a refund or replacement parts. The warranty does not cover defects from accidents, misuse, abuse, neglect, or unauthorized service. The goods come with guarantees under Australian Consumer Law, entitling consumers to replacement or refund for major failures. Customers should retain their receipt as proof of purchase for warranty claims.
Business Contact Information:
- Business Name: Hunter Products Pty Ltd
- Business Address: Level 2, 424 Warrigal Road, Moorabbin VIC 3189, Australia
- Toll Free Phone: 1800 224 094 (Monday to Friday 9.00 to 5.00pm AEST)
- Email Address: enquiries@hunterproducts.com.au
To Next Page
General
