Hyper Split HS22T - Trouble Shooting

!!!!!!!!!Hyper Split Hydraulic Log Splitter!
ToolTuff!Direct!LLC,!15000!W44th!Ave,!Ste!B,!Golden!CO!80403!!!!!!!!!!!!!!Page!10!
Trouble$Shooting$
Problem$
!
Cylinder!rod!will!not!move!
Solution:!A;D;E;H;J!
Slow!cylinder!rod!speed!when!
extending!or!retracting!
Solution:!A;B;!C;!H;!I;!K;!L!
Wood!will!not!split!or!splits!
extremely!slowly!
Solution:!A;!B;!C;!F;!I;!K!
Engine!bogs!down!during!splitting!
Solution:!G;!L!
Engine!stalls!under!low!load!
condition!
Solution:!D;!E;!L;!M!
Engine!starts!problem!
Solution:!N!
Cause$
Solution$
A-Insufficient!oil!to!pump!
Check!oil!level!in!reservoir!
B-Air!in!oil!
Check!oil!level!in!reservoir!
C-Excessive!pump!inlet!vacuum!
Check!pump!inlet!hose!for!
blockage!or!kinks!
D-Blocked!hydraulic!lines!
Flush!and!clean!the!splitter!
hydraulic!system!
E-Blocked!control!valve!
Flush!and!clean!the!splitter!
hydraulic!system!
F-Low!control!valve!setting!
Adjust!control!valve!with!a!
pressure!gauge!
G-High!control!valve!setting!
Adjust!control!valve!with!a!
pressure!gauge!
H-Damaged!control!valve!
Return!control!valve!for!
authorized!repair!
I-Internal!control!valve!leak!
Return!control!valve!for!
authorized!repair!
J-Internal!cylinder!leak!
Return!cylinder!for!authorized!
repair!
K-Internally!damaged !cylinder!
Return!cylinder!for!authorized!
repair!
L-Engine!control!out!of!adjustment!
Adjust!idle!control!nuts!
M-Engine!is!loaded!during!idle!
down!mode!
Use!shorter!log!length!to!allow!
engine!to!speed!up!before!contract!
N-Engine!operation!
Refer!to!the!engine!owner’s!
manual!