Home
iDirect
Network Router
Evolution 8000 Series
iDirect Evolution 8000 Series Installation And Safety Manual
4
of 1
of 1 rating
90 pages
Give review
Manual
Specs
To Next Page
To Next Page
Loading...
Installation and Safety M
anual
Evolution 8000 Ser
ies Satellite Router
TM
Router Products
Models e8350 & iCONNEX e800
February 11, 2009
2
Table of Contents
Table of Contents
3
About this Manual
11
Intended Audience
11
Manual Contents
11
Document Conventions
12
Safety Definitions
12
Table 1. Safety Definitions
12
Disclaimer
13
Iconnex E800 Warranty, Restrictions and Disclaimer
13
Restrictions
13
Disclaimer of Warranty
14
Getting Help
14
Introduction
15
Figure 1. Front View of the E8350 Satellite Router
15
Safety Information
17
Installation Guidelines
17
Electrical Safety
19
Physical and Environmental Considerations
19
Operational and Maintenance Safety
21
Safety Guidelines to Observe During Servicing
21
Servicing
21
Conditions Requiring Service
21
Evolution 8000 Series Specifications
23
E8350 Satellite Router Specifications
23
Mechanical and Environmental Specifications
23
Table 2. E8350 Satellite Router Mechanical and Environmental Specifications
23
Power Specifications
24
Table 3. E8350 Satellite Router Power Specifications
24
RF Specifications
25
Table 4. E8350 Satellite Router RF Specifications
25
Iconnex E800 Satellite Router Specifications
26
Mechanical and Environmental Specifications
26
Table 5. E800 Iconnex Satellite Router Mechanical and Environmental Specifications
26
Power Specifications
27
Table 6. E800 Iconnex Satellite Router Power Specifications
27
RF Specifications
28
Table 7. E800 Iconnex Satellite Router RF Specifications
28
Installing Your E8350 Satellite Router
31
Tools and Supplies Required for Installation
31
Table 8. Recommended Tools
31
Figure 2. Installation Tools
32
Figure 3. DB-9 to RJ-45 Adapter and Connector
32
Unpacking Your E8350 Satellite Router
33
Components Normally Included in an Order
33
Figure 4. Mounting Ears for the Evolution E8350 Satellite Router
33
Additional Components Normally Required
34
Mounting the E8350 Satellite Router
35
General Guidelines for Mounting Configurations
35
Guidelines for Desktop or Shelf Mounting
35
Guidelines for Rack Mounting
35
Defining the E8350 Satellite Router Rear Panel
36
Table 9. E8350 Satellite Router Connectors
37
Table 10. RJ-45 Pin Assignments
37
Figure 8. GPIO/RS-232 Port Pin Numbering
39
Table 11. RS-232 Serial Connector Pin Assignments
39
Preparing the Coax Cables
40
Figure 9. Recommended Tools for Terminating Coaxial Cable
41
Figure 10. Coax Cable Cutting Technique
42
Table 12. Coax Trim Dimensions
42
Figure 11. Cutting Technique for Removing Foil in the Braid
43
Figure 12. Folding the Braid
43
Figure 13. Attaching the RG-11 Connector
44
Figure 14. Crimp Area for F-Type Plugs
44
Console Port Cable Specifications and Pinout
45
Figure 15. Proper Center Connector Length and Crimping Technique
45
Figure 16. Holding the RJ-45 Cable Connectors
46
Table 13. RJ-45 to DB-9 Pinouts
46
Figure 17. RJ-45 to DB-9 Female DTE Adapter
47
Ethernet Port Cable Specifications and Pinouts
48
Connecting AC Power
48
Figure 18. RJ-45 Cable Connectors, Plug and Receptacle
48
Table 14. RJ-45 Connector Pin Assignments
48
Preparing Your Pc/Laptop
49
Checking Conditions before Powering up the System
49
Powering up the System
49
Table 15. LED Status
50
Monitoring LED Status Indicators
51
Front Panel Power and Network LED Status Indicators
51
Front and Rear Panel LED Status Definitions
52
Table 16. Front Panel LED Indicators
52
Maintaining the Remote
53
Table 17. Rear Panel LED Indicators
53
Temperature Control
54
Dust Removal
54
Repacking the E8350 Satellite Router
55
Iconnex E800 Physical Interfaces
57
Iconnex E800 Satellite Router Interface Specifications
57
Power Connectors
59
Table 18. E800 Iconnex Satellite Router Port Specifications
59
Iconnex E800 Satellite Router Remote ON/OFF Switch Connector
60
Iconnex E800 Satellite Router Remote LED Connector
60
Figure 21. JP1 Pin Numbering
60
Figure 22. JP2 Pin Numbering
60
Table 19. JP1 Pin Assignments
60
Table 20. JP2 Connector Pin Assignments
60
Iconnex E800 Satellite Router DC Power Connector
61
Figure 23. JP18 Pin Numbering
61
Table 21. JP18 Pin Assignments
61
Console Port Cables
62
Console Port Pin Assignments
63
Figure 25. RJ-45 to DTE Adapter Pin Identification
63
Figure 26. Console Pin Numbers
63
Table 22. E800 Iconnex Satellite Router Console Pin Assignments
63
LED Status and Definitions
64
Front Edge Status Leds
64
Table 23. Front Panel Leds
64
Rear Panel Status Leds
65
Circuit Board Temperature Monitor
65
Table 24. Rear Panel Leds
65
Configuring the Iconnex E800 as a Mobile Remote
67
What Is a Mobile Remote
67
Hardware Connections for a Mobile Remote
68
Figure 27. Iconnex E800 Hardware Connections Diagram
68
GPS Receiver Specification
69
Iconnex E800 GPS Port Pin Assignments
69
Figure 28. HD-15 Pin Numbers
69
Table 25. HD-15(F) RS-232 Serial Port Pin Assignments
69
Handshake Signals
70
GPS Information
70
Configuring a Mobile Remote
71
Monitoring a Mobile Remote
71
Warnings for the E8350 Satellite Router
73
Danger/Warning Symbol
73
Installation Warning
74
Restricted Area Warning
75
Service Personnel Warning
76
Qualified Personnel Warning
77
Operating Temperature and Airflow Warning
77
Lightning Activity Warning
78
Safety Extra-Low Voltage Port Warning
79
Ground Conductor Warning
80
AC Power Supply Circuit Warning
82
Compliance for the E8350 Satellite Router
83
Figure 29. Evolution 8000 Series Satellite Router Product Label
83
FCC Compliance
84
Part 15 Compliance
84
Canadian Labeling Requirements
84
CE Compliance (European Union)
85
Safety
85
Rohs and WEEE Compliance
86
Compliance with Rohs Directive (2002/95/EC)
86
Compliance with WEEE Directive (2002/96/EC)
86
Declaration of Conformity
87
Other manuals for iDirect Evolution 8000 Series
Installation Guide
130 pages
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the iDirect Evolution 8000 Series and is the answer not in the manual?
Ask a question
iDirect Evolution 8000 Series Specifications
General
Brand
iDirect
Model
Evolution 8000 Series
Category
Network Router
Language
English
Related product manuals
iDirect evolution x5
130 pages
iDirect Evolution X7
62 pages
iDirect iconnex e800
130 pages
iDirect iconnex e850
130 pages
iDirect X1
90 pages
iDirect iQ Desktop+
52 pages
iDirect iQ 200
58 pages
iDirect iNFINITI 3000
72 pages
Need help?
General
To Next Page
