Johnson Controls Unitary Products EB10F Installation Manual

Johnson Controls Unitary Products 5165699-BIM-C-0516
ELECTRIC FURNACE
MODELS: EB**F
Downflow/Upflow
INSTALLATION MANUAL
®
LIST OF SECTIONS
GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1
SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
UNIT INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
DOWNFLOW FURNACE INSTALLATION . . . . . . . . . . . . . . . . . . . . . 3
THERMOSTAT INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
OPTIONAL AIR CONDITIONING ACCESSORIES . . . . . . . . . . . . . . 9
WIRING DIAGRAMS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
LIST OF FIGURES
Furnace Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1
Upflow Closet Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Duct Connector Depth (7990 Series) . . . . . . . . . . . . . . . . . . . . . . . . . .4
Duct Connector Dimensions (7990 Series) . . . . . . . . . . . . . . . . . . . . .4
Recommended Floor Cut-out (7990 Series) . . . . . . . . . . . . . . . . . . . .4
Duct Connector Screw Attachment (7990 Series) . . . . . . . . . . . . . . . .5
Duct Connector Tab Attachment (7990 Series) . . . . . . . . . . . . . . . . . .5
Duct System Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Installation of Furnace . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Hanger Angle Attachment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Blower Bracket and Duct Flange Attachment . . . . . . . . . . . . . . . . . . .6
Control Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Field Wiring Shield . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Thermostat Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Thermostat Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
EB10F Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
EB12F Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
EB15F Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
EB17F Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
EB20F Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
EB23F Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
LIST OF TABLES
Duct Connector for Electric Furnaces . . . . . . . . . . . . . . . . . . . . . . . . .4
Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
EB Series Blower Performance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Electrical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
SECTION I: GENERAL
The following list includes important facts and information regarding the
EB furnace and its packaging inclusions:
1. Furnace is rated at 240 volts, 60 Hz, single phase.
2. Filters are furnished with each model, and are the same for all
models - 16 x 20 x 1 in top and 20 x 20 x 1 in the louvered door.
3. Furnace size is the same for all models. See Figure 1.
4. Four-wire thermostat operation for heating and cooling.
5. Coil cavity built into furnace (coil shelf accessory required).
6. All furnaces are equipped with an air conditioner blower and is A/C
or Heat Pump ready (coil shelf accessory required).
7. Holding strap furnished on top rear of furnace.
8. This furnace is designed for downflow application; however, it may
be converted to an upflow application. (See Page 6 for upflow con-
version instruction.)
9. This furnace must not be operated without the front panel
installed.
NOTICE
This furnace and its components listed on the A/C and Heat Pump
equipment sticker are listed in combination as a system by Under-
writer's Laboratories for the United States and Canada.
FIGURE 1: Furnace Dimensions
´
´
237,21$/%27720),(/'
:,5,1*(175<
$
%
&
'
(
)
+
*
-
.
/
0
1
´
´
´
´
´
´
´
´
´
´
´
´
´
-
+
&
%
$
'
(
)
*
1
0
/
.
68%%$6(,)
86('$''6
´025(72
727$/+(,*+7
$1'´72
:,'7+
7+(50267$7
:,5,1*
(175<
),(/'
:,5,1*
(175<
$
´

Johnson Controls Unitary Products EB10F Specifications

General

Brand	Johnson Controls Unitary Products
Model	EB10F
Category	Furnace
Language	English