Jøtul GF 370 DV User Manual

Jøtul GF 370 DV
Direct Vent Gas Stove
Installation and
Operation Instructions
– Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
– WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not
use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone. Follow the gas supplier’s
instructions.
• If you cannot reach your gas supplier, call
the fire department.
– Installation and service must be performed
by a qualified installer, service agency or the
gas supplier.
– In the Commonwealth of Massachusetts,
a carbon monoxide (CO) detector shall be
installed in the same room as the appliance.
WARNING: If the information in these
instructions is not followed exactly, a fire
or explosion may result causing property
damage, personal injury or loss of life.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
– QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE
GAZ:
• Ne pas tenter d’allumer l’appareil.
• Ne touchez à aucum interrupteur. Ne
pas vous servir des téléphones se trou-
vant dans le bâtiment où vous trouvez.
• Appelez immédiatement votre fournis-
seur de gaz depuis un voisin. Suivez les
instructions du fournisseur.
• Si vou ne pouvez rejoindre le fournis-
seur de gaz, appelez le service des incend-
ies.
– L’installatione l’entretien doivent être
assurés par un installateur ou un service
d’entretien qualifié ou par le fournisseur
de gaz.
– Ne pas entreposer ni utiliser d’essence ni
d’autres vapeurs ou liquides inflammables
dans le voisinage de cet appareil ou de tout
autre appareil.
AVERTISSEMENT: Assurez-vous de bien suiv-
reles instructions données dans cette notice
pour réduire auninimum le risque d’incendie
ou d’explosion ou pour éviter tout dommage
matériel, toute blessure ou la mort.
ATTENTION : CES INSTRUCTIONS DOIVENT
DEMUERER AVEC LE PROPRIÉTERE D’UNE
MAISON.
This appliance may be installed in an aftermarket,
permanently located, manufactured home or mobile
home, where not prohibited by local codes.
This appliance is only for use with the types of gas
indicated on the rating plate. A conversion kit is
supplied with the appliance.

Jøtul GF 370 DV Specifications

General

Model	GF 370 DV
Category	Stove
Vent Type	Direct Vent
Flame Adjustment	Manual
Log Length	18 inches
Material	Cast Iron

Summary

Suggested Tools for Installation and Service

Installation and Service Tool Requirements

Critical Safety Warnings

Highlights vital safety alerts regarding hot surfaces, proper installation, and appliance modification.

Specifications, Accessories, and Test Standards

Technical Specifications (Input Rates, Pressure, Efficiency)

Detailed technical data including gas input, pressure, and efficiency ratings for the appliance.

General Information and Installation Requirements

Mandatory Qualified Service Agency

Emphasizes that installation and servicing must be performed by a qualified professional.

Appliance Safety Guidelines

Comprehensive Safety Information

Operating Temperature and Fire Hazard Warnings

Alerts regarding high operating temperatures, proximity to combustibles, and flammable materials.

Electrical Safety and Grounding Precautions

Warnings about electrical shock hazards and the importance of proper grounding and power disconnection.

Child Safety and User Operation Responsibility

Instructions for supervising children and ensuring only trained individuals operate the appliance.

Installation Requirements

Stove Location and Hearth

Clearance Specifications

Minimum required clearances from the stove and vent pipe to combustible materials and structures.

Venting Requirements

Vertical Venting and Termination

Vent Termination Configurations

Horizontal Vent Termination

Chimney Conversion Guidelines

Vent Restriction Adjustments

Exhaust Vent Restriction Adjustment

Intake Air Shutter Adjustment

Stove Assembly Procedures

Gas Supply Connection Requirements

Critical instructions for connecting the gas supply, including shut-off valves and code compliance.

Gas Leak Testing and Pressure Checks

Soap Solution Leak Test

Method for checking gas connections for leaks using a soap solution.

Testing Gas Pressure and Symptoms

Guidance on testing gas pressure and identifying issues from incorrect pressure.

Fuel Conversion Procedure

Required Tools and Kit Contents

Step-by-Step Fuel Conversion

Detailed instructions for converting the appliance from natural gas to propane or vice versa.

Initial System Check

System Check Procedure

Steps to verify all system components and functions are operating correctly after installation.

Pilot Flame Inspection and Adjustment

How to inspect the pilot flame pattern and adjust it for optimal ignition and stability.

Flame Appearance and Air Shutter Adjustment

Adjusting Primary Air Shutter

Instructions for adjusting the air shutter to achieve desired flame appearance and prevent soot.

Operation Overview and System Features

Proflame GTMFS System Features

Control Functions and Pilot Modes

Pilot Mode Selection (IPI vs. CPI)

Explanation of Intermittent Pilot Ignition (IPI) and Continuous Pilot Ignition (CPI) modes.

Remote Receiver and Transmitter Operation

How to operate the remote receiver settings and understand the transmitter controls.

Remote Control Operations

Burner On/Off and Flame Level Control

Room Thermostat Functionality

Technical Data and Wiring Schematics

Fan Control Module and Receiver Specifications

Maintenance Procedures

Annual Cleaning and Inspection

Glass Care and Gasket Inspection

Glass Panel or Gasket Replacement

Jøtul Gas Product Limited Warranty

Warranty Coverage and Terms

Exclusions, Limitations, and Claims Process

Information on what is not covered by the warranty and how to submit a claim.

Lighting Instructions and Safety Precautions

Pre-Lighting Safety Warnings

Critical safety advice to follow before attempting to light the appliance, including gas detection.

Appliance Lighting Procedure

Step-by-step instructions for safely lighting the pilot and main burner of the appliance.

Procedure to Turn Off Gas